Club Touareg Forum banner

First time using VCDS

6K views 14 replies 5 participants last post by  New2Tregs 
#1 ·
Just bought a VCDS scanner because my HVAC system went out. Ran a scan and pulled the following. At the moment, I am really only interested in clearing the HVAC codes and will get to the others eventually. I was wondering if anyone could help point me in the right direction on deciphering them. From what I've found here is that its likely the HVAC blower that needs replacing. Any input is appreciated.


01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: Malfunction 0010
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
69-Trailer -- Status: Malfunction 0010
6C-Back-up Cam. -- Status: OK 0000
6D-Trunk Elect. -- Status: Malfunction 0010
72-Door, Rear Right -- Status: OK 0000
-----------------------------------

Address 01: Engine (J623-CGRA) Labels:. 03H-907-309-V1.clb
Part No SW: 03H 906 023 B HW: 03H 907 309
Component: 3,6 FSI ULEV2 H15 8643
Revision: M7H15---
Coding: 002A0012433600000000
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_ECM36FSI01103H906023B 002005
ROD: EV_ECM36FSI01103H906023B.rod
VCID: 211FECDF5145D433A0D-8074
8 Faults Found:
14627 - Fuel Pump Control Module
P025A 00 [040] - Electrical Fault
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 229
Mileage: 138226 km
Date: 2018.12.21
Time: 15:18:52
Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 255 km/h
Coolant temperature: 17 °C
Intake air temperature: 15 °C
Ambient air pressure: 960 mbar
Voltage terminal 30: 11.355 V
Unlearning counter according OBD: 38
Fuel pump: specified value: 70.000 %
Low fuel pressure: specified value: 529.6 kPa
Fuel temperature: 18.0 °C
Fuel pump adaptation: 24.4 kPa
High fuel pressure: specified value: 6.9230 MPa
Fuel low pressure: actual value: 309.0 kPa
High pressure regulation: adaptation value: 0.0000 MPa
5582 - Oil Pressure Switch for reduced Oil Pressure
P164D 00 [032] - Malfunction
Intermittent - Not Confirmed - Tested Since Memory Clear
12348 - Coolant Pump 2
P261A 00 [096] - Open circuit
Intermittent - Not Confirmed - Tested Since Memory Clear
4865 - No Communication with Towing System Control Module (J345)
U1003 00 [032] - -
[Towing recognition control module -J345No Communication]
Intermittent - Not Confirmed - Tested Since Memory Clear
9017 - Oxygen (Lambda) Sensor Signal B2 S2
P2273 00 [096] - too Rich
Intermittent - Not Confirmed - Tested Since Memory Clear
2921 - Knock Sensor 1 (G61)
P0328 00 [096] - Signal too High
Intermittent - Not Confirmed - Tested Since Memory Clear
2925 - Knock Sensor 2 (G66)
P0333 00 [096] - Signal too High
Intermittent - Not Confirmed - Tested Since Memory Clear
7666 - EVAP System
P0456 00 [096] - Very Small Leak Detected
Intermittent - Not Confirmed - Tested Since Memory Clear

Address 08: Auto HVAC (J255) Labels:| 7P6-907-040.clb
Part No SW: 7P6 907 040 AG HW: 7P6 907 040 AG
Component: Klima 2 Zonen H18 0613
Coding: 4606200A80
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_AirCondiFront 004001
ROD: EV_AirCondiFront_VW52.rod
VCID: 79AFE4BF99556CF3C8D-802C
6 Faults Found:
0251 - Air Blower
B10BE 12 [008] - Short to Plus
[Frischluftgebläse Kurzschluss nach Plus]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 3
Fault Frequency: 102
Reset counter: 44
Mileage: 189984 km
Date: 2021.04.05
Time: 12:25:56
0256 - Control Module for Air Blower
B10BB 96 [008] - Component internal failure
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 3
Fault Frequency: 1
Reset counter: 42
Mileage: 190995 km
Date: 2021.05.09
Time: 13:37:35
0258 - Control Module for Air Blower
B10BB 04 [008] - Internal System Fault
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 3
Fault Frequency: 5
Reset counter: 35
Mileage: 190650 km
Date: 2021.05.04
Time: 20:31:18
15360256 - Component Protection
U1101 00 [008] - Active
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 1
Fault Frequency: 2
Reset counter: 50
Mileage: 190678 km
Date: 2021.05.07
Time: 19:37:00
0309 - Local data bus 2
U1076 00 [009] - Electrical malfunction
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 63
Reset counter: 15
Mileage: 190789 km
Date: 2021.05.08
Time: 09:37:35
0243 - Function Restriction due to Faults in Other Modules
U1113 00 [008] - -
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 3
Reset counter: 45
Mileage: 191040 km
Date: 2021.05.11
Time: 07:40:14
 
See less See more
#4 ·
1st, clear them and see if they return. Sometimes they return, sometimes its all good.

..and i think your battery is close to dead. This can trigger all the above problems.
Do you mean clear them in the open controller window? I did clear them for the HVAC controller, rescanned, and this is what came back. I wasn't sure I was doing it correctly since none of the original codes came back. If this is the correct way of doing it, I will clear the engine codes and rescan.

Address 08: Auto HVAC (J255) Labels:| 7P6-907-040.clb
Part No SW: 7P6 907 040 AG HW: 7P6 907 040 AG
Component: Klima 2 Zonen H18 0613
Coding: 4606200A80
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_AirCondiFront 004001
ROD: EV_AirCondiFront_VW52.rod
VCID: 79AFE4BF99556CF3C8D-802C
2 Faults Found:
15360256 - Component Protection
U1101 00 [008] - Active
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 68
Mileage: 192043 km
Date: 2021.06.07
Time: 11:33:29
0309 - Local data bus 2
U1076 00 [009] - Electrical malfunction
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 11
Reset counter: 28
Mileage: 192019 km
Date: 2021.06.02
Time: 19:32:26
 
#8 · (Edited)
Just replace it with OEM
 
#9 ·
I charged the battery overnight, cleared the DTCs, and rescanned. Only one code came back:

Address 08: Auto HVAC (J255) Labels:| 7P6-907-040.clb
Part No SW: 7P6 907 040 AG HW: 7P6 907 040 AG
Component: Klima 2 Zonen H18 0613
Coding: 4606200A80
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_AirCondiFront 004001
ROD: EV_AirCondiFront_VW52.rod
VCID: 79AFE4BF99556CF3C8D-802C
1 Fault Found:
0309 - Local data bus 2
U1076 00 [009] - Electrical malfunction
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 30
Mileage: 192043 km
Date: 2021.06.08
Time: 12:10:53
 
#12 ·
Blower motor imho but I would locate it and see if the brushes are gunked up or worn ot and check for power. Don't rush into buying a new one. Where is it located? No idea but guessing down behind the glovebox area, take the glovebox out job.

I think the speed controller is part of the motor and not just a resister but a electronic SCR type. I will try & find the part number.
 
This is an older thread, you may not receive a response, and could be reviving an old thread. Please consider creating a new thread.
Top