Club Touareg Forum banner
1 - 5 of 5 Posts

·
Registered
Joined
·
25 Posts
Discussion Starter · #1 ·
2005 V8 won't start. I've had the Kessy rebuilt with new mosfets and transistors. The vehicle has q fully charged battery and there's power to everything. I can also remove it from park. I'll upload the VAG report when I get some replies to this thread.
Any ideas on what could be causing this?
From reading the forums I thought it was the Kessy but to no avail.
 

·
Registered
Joined
·
25 Posts
Discussion Starter · #4 ·
Here is the VCDS report, attached also.

VIN: WVGMM77L15D002155 License Plate: 902-SMD
Mileage: 185780km-115438mi Repair Order:



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 7L (7L - VW Touareg (2003 > 11/2006))
Scan: 01 02 03 05 06 08 09 11 13 15 16 17 18 19 1C 22 29 32 34 36
37 39 3C 46 47 55 56 57 64 65 68 69 6C 6D 6E 75 76 77

VIN: WVGMM77L15D002155 Mileage: 185780km-115438miles
-------------------------------------------------------------------------------
Address 01: Engine Labels: 077-907-560-AXQ.lbl
Part No SW: 4D0 907 560 DB HW: 8E0 907 560
Component: 4.2L V8/5V G X010
Coding: 0007875
Shop #: WSC 31414 000 00000
VCID: 69DE258B436A4569D91-5000

No fault code found.
Readiness: 0110 1101

-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 09D-927-750.lbl
Part No: 09D 927 750 AQ
Component: AL 750 6A 0903
Coding: 0004153
Shop #: WSC 02107 444 84430
VCID: 7DF661DB27E2C9C9059-5000

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 7L0-907-379-MK25.lbl
Part No: 7L0 907 379 E
Component: ESP ALLRAD MK25 0202
Coding: 0014594
Shop #: WSC 31414 000 00000
VCID: 3B72AFC3797607F97BD-5000

1 Fault Found:
00778 - Steering Angle Sensor (G85)
000 - -

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. Labels: 3D0-909-13x-05.lbl
Part No SW: 3D0 909 135 M HW: 5WK 470 26
Component: Kessy 6400
Coding: 0131304
Shop #: WSC 31414 000 00000
VCID: 2F6A8B93BD0EEB59C75-50E6

Subsystem 1 - Part No: XXXXXXXXXXX
Component: ELV XXXX

2 Faults Found:
00179 - Access/Start Authorization Antenna; Drivers Side (R134)
011 - Open Circuit
00180 - Access/Start Authorization Antenna; Passenger Side (R135)
011 - Open Circuit

-------------------------------------------------------------------------------
Address 06: Seat Mem. Pass Labels: None
Part No: 7L0 959 760
Component: Sitzverstellung 0701
Shop #: WSC 00000 000 00000
VCID: 77FA73F305DEE3995F5-5000

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 7L6-907-044.clb
Part No: 7L6 907 044 H
Component: CLIMAtronic 2+2 X 3717
Coding: 0000030
Shop #: WSC 31414 000 00000
VCID: 397EB5CB734A35E9691-5000

Subsystem 1 - Part No: 7L6 907 049 C
Component: CLIMAtronic FOND X 0306

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 7Lx-937-049-V1.clb
Part No: 7L6 937 049 K
Component: 2703
Coding: 0105695
Shop #: WSC 31414 000 00000
VCID: 4480D43F048878010A7-5000

1 Fault Found:
00907 - Intervention load Management
000 - -

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 3D0-909-601.lbl
Part No: 3D0 909 601 C
Component: 05 Airbag 8.4E++H01 0352
Revision: BB36963 Serial number: 00022646
Coding: 0012341
Shop #: WSC 31414 000 00000
VCID: 234277A3E1C65F3953D-5072

Subsystem 1 - Part No: 7L0 959 339 D
Component: BF-Gewichtsens. 005 0007

1 Fault Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 2
Fault Frequency: 1
Reset counter: 39
Time Indication: 0
Date: 2063.15.31
Time: 31:60:00


-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 7L6-953-549.lbl
Part No: 7L6 953 549 E
Component: Lenksäulenmodul 3301
Coding: 0000232
Shop #: WSC 31414 000 00000
VCID: 418EDD2B1B9A6D29211-5000

1 Fault Found:
00455 - Control Module for Access and Start Control; Comfort CAN (J518)
004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 17: Instruments Labels: 7L6-920-xxx-7LA.lbl
Part No: 7L6 920 980 M
Component: KOMBIINSTRUMENT RB8 2935
Coding: 0023231
Shop #: WSC 02107 444 84430
VCID: 428CD2271E9C763138B-5000

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 6N0-909-901-19.lbl
Part No: 6N0 909 901
Component: Gateway K<>CAN 0101
Coding: 0000006
Shop #: WSC 31414 000 00000
VCID: 70E848EF60B0B4A19EF-5000

1 Fault Found:
01327 - Control Module for Parking Aid (J446)
004 - No Signal/Communication

-------------------------------------------------------------------------------
Address 1C: Position Sensing Labels: 7L6-919-879.lbl
Part No: 7L6 919 879
Component: JCI PathPoint 1700
Shop #: WSC 00000 000 00000
VCID: 0400143F4408B8014A7-5000

2 Faults Found:
00926 - Terminal 30
002 - Lower Limit Exceeded - Intermittent
00455 - Control Module for Access and Start Control; Comfort CAN (J518)
004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 22: AWD Labels: None
Part No: 0AD 927 755 BE
Component: TRANSFERCASE 0122
Shop #: WSC 00000 000 00000
VCID: 7F0A9BD32DEEDBD9175-5072

No fault code found.

-------------------------------------------------------------------------------
Address 29: Left Light Labels: 3D0-909-157.lbl
Part No: 3D0 909 157
Component: EVG GDL+AutoLWR(l) 0001
Coding: 0000003
Shop #: WSC 31414 000 00000
VCID: 66C42EB752746A11F43-5000

1 Fault Found:
00492 - Body Pitch Angle from Level Control Module
008 - Implausible Signal - MIL ON

-------------------------------------------------------------------------------
Address 34: Level Control Labels: 7Lx-907-553-34.clb
Part No: 7L0 907 553 F
Component: LUFTFDR.-CDC- 3C3P1 3081
Coding: 0015521
Shop #: WSC 31414 000 00000
VCID: 3664BEF74254DA91843-5000

1 Fault Found:
00778 - Steering Angle Sensor (G85)
004 - No Signal/Communication

-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr Labels: None
Part No: 7L0 959 760
Component: Sitzverstellung 0701
Shop #: WSC 00000 000 00000
VCID: 77FA73F305DEE3995F5-5000

2 Faults Found:
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
01898 - Steering Column Axial Adjustment Sensor (G358)
006 - Short to Plus - Intermittent

-------------------------------------------------------------------------------
Address 37: Navigation Labels: 7L6-919-887-CD.lbl
Part No: 7L6 919 887 D
Component: Navigation 0635
Coding: 0000002
Shop #: WSC 31414 000 00000
VCID: 479AC33335BE5319EF5-5000

No fault code found.

-------------------------------------------------------------------------------
Address 39: Right Light Labels: 3D0-909-158.lbl
Part No: 3D0 909 158
Component: EVG GDL+AutoLWR(r) 0001
Coding: 0000003
Shop #: WSC 31414 000 00000
VCID: 67DA23B3557E7319CF5-5000

1 Fault Found:
00492 - Body Pitch Angle from Level Control Module
008 - Implausible Signal - Intermittent

-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 7L0-959-933.lbl
Part No: 7L0 959 933 G
Component: 2M HSG 3213
Coding: 0000085
Shop #: WSC 02107 444 84430
VCID: 4088D82F109064212EF-4A3A

Subsystem 1 - Part No: 7L0 959 701 B
Component: Tuersteuergeraet FS 0201

Subsystem 2 - Part No: 7L0 959 702 B
Component: Tuersteuergeraet BF 0201

Subsystem 3 - Part No: 7L0 959 703 B
Component: Tuersteuergeraet HL 0201

Subsystem 4 - Part No: 7L0 959 704 B
Component: Tuersteuergeraet HR 0201

10 Faults Found:
00927 - Terminal 30 (Right)
011 - Open Circuit - Intermittent
01516 - Terminal 30; Left
011 - Open Circuit - Intermittent
00926 - Terminal 30
011 - Open Circuit - Intermittent
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
00470 - Company Comfort Databus in Single Wire
011 - Open Circuit - Intermittent
01331 - Door Control Module; Driver Side (J386)
002 - Lower Limit Exceeded - Intermittent
01332 - Door Control Module; Passenger Side (J387)
002 - Lower Limit Exceeded - Intermittent
01333 - Door Control Module; Rear Left (J388)
002 - Lower Limit Exceeded - Intermittent
00930 - Locking Module for Central Locking; Rear Left (F222)
008 - Implausible Signal
01334 - Door Control Module; Rear Right (J389)
002 - Lower Limit Exceeded - Intermittent

-------------------------------------------------------------------------------
Address 47: Sound System Labels: 7Lx-035-4xx-47.lbl
Part No: 7L6 035 466
Component: 12K-AUDIOVERST 0108
Shop #: WSC 00000 000 00000
VCID: 71EE4DEB6BBABDA9911-5000

2 Faults Found:
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
00464 - Control Module with Display for Radio and Navigation (J503)
004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 56: Radio Labels: 7L6-035-186-CD.lbl
Part No: 7L6 035 186 A
Component: Radio 0635
Coding: 0005077
Shop #: WSC 00001 552 00000
VCID: 316E8DEBAB3AFDA9D11-5000

No fault code found.

-------------------------------------------------------------------------------
Address 68: Wiper Electr. Labels: 7L0-955-119-V1.clb
Part No: 7L0 955 119 F
Component: Front Wiper 2416
Coding: 0000004
Shop #: WSC 00000 000 00000
VCID: 377AB3F3455E23999F5-5000

No fault code found.

-------------------------------------------------------------------------------
Address 6E: Ctrl Head Roof Labels: 7L6-919-044.lbl
Part No: 7L6 919 044 F
Component: DACHDISPLAY 0535
Revision: 7005 Serial number: #009289.02 B
Shop #: WSC 31414 000 00000
VCID: 3A7CAAC7764C3EF160B-5000

1 Fault Found:
00446 - Function Limitation due to Under-Voltage
002 - Lower Limit Exceeded - Intermittent

End-------------------------(Elapsed Time: 10:15)--------------------------
 

Attachments

·
Registered
2006 V8 Touareg AIR, nav, hid
Joined
·
4,436 Posts
Look under the left and right front engine covers and verify the timing belt is fine.Take 2 minutes a side.

Next, have a battery charger connected while doing all testing/checking. You are getting a lot of under voltage errors.

I would then clear all codes and re-run the scan (and save the scan).

I would then try to start it and re-run the scan (and save the scan).

After that, it depends on the scans.

If I got a lot of random errors, I would be looking at the wiring harness as we have a established problem in some cars.

If I got a pretty clean scan, I would start looking at the (CPS) Crankcase Position Sensor.
 
1 - 5 of 5 Posts
Top