Club Touareg Forum banner

Search results

1-20 of 34 Results
Advanced Search
  1. V10 Vac Diagram? and P0299 underboost.

    General Maintenance & Repair
    I'll try to get this done right away. My only concern is would the P0299 error with Limp mode negate this information? I am concerned as it seems to get triggered once RPMs get to about 2-2.5K or higher.
  2. V10 Vac Diagram? and P0299 underboost.

    General Maintenance & Repair
    Thanks guys for all the info. I'm planning on getting a better look tonight. That being said. I'm posting my turbo responses for both sides of the engine. Green indicates the requested boost and yellow is measured boost. The lighter shades are the more properly running Bank 1/Driver side, and...
  3. V10 Vac Diagram? and P0299 underboost.

    General Maintenance & Repair
    That explains not seeing the vacuum lines for the actuators in the drawings. Is it possible to see the Engine 11/passenger side turbo actuator, without tearing much apart the vehicle? Also, if charge lines are good, and no leaks, would "Revive" or the Wynn turbo cleaners be helpful to unstick...
  4. Vnt actuator rebuild or replace

    Diesel Engines | R5, V6, V8, V10, R50 TDI
    Hey guys, any resolution to this issue? I am getting a low boost P0299 on my bank 2 as well. I ordered some vac lines as I read here that it can cause the problem. However, I'm not sure where to start as the actuators are electric activated right? Really, at a loss on where to look first...
  5. V10 Vac Diagram? and P0299 underboost.

    General Maintenance & Repair
    Hi all, Been searching the site here looking for info. Recently, I've been getting some intermittent P0299 underboost errors on the Engine 2 side. I checked measure block 11 and the boost appears low but is following the request normally. From searching, it appears this may be an issue of leaks...
  6. help, part # or diagram for Vacuum lines.

    General Maintenance & Repair
    I know this is ridiculously old post, but if you have a diagram for the V10 (07 if matters), and are still here, I would be So thankful.
  7. Add tpms to 2007 touareg.

    Brakes, Steering, Suspension, Wheels and Tires
    I have a 2006 touareg that doesnt have tpms on the tires. How difficult is this to add? Can I just install the tpms sensors in the tires and then make a change in vag-com? Or is it more complicated than that? Thanks for the input.
  8. Looking for a long lasting All weather tire for '07 TDI...Nitto Grappler G2? Nokian?

    Brakes, Steering, Suspension, Wheels and Tires
    Hi all, Yes it is another what tire thread. I have a '07 V10 TDI that is need of new tires. My previous set were the Perelli Scorpion Verdes, and they got a little less than 1/3 or what they should 20K/65K. I have seen around that the Pirellis seem to have a low mileage history with these guys...
  9. Restoring a V10 to previous luster...advice?

    General Maintenance & Repair
    I should also mention that there appears to be a bit of hesitation when starting from a stop, and a bit of build up in the EGR lines when the generator was replaced. This led me towards the injector cleaner idea.
  10. Restoring a V10 to previous luster...advice?

    General Maintenance & Repair
    Hi all, I recently purchased a v10 and have just finished replacing both the a/c compressor, generator, and now rebuild the air suspension compressor. I would like to restore this to it's former glory if possible and was wondering if there were suggestion on what process I should take. I am...
  11. Air suspension, compressor won't shut off!

    Brakes, Steering, Suspension, Wheels and Tires
    I've just been relying on the normal start up process. How would I go about turning the compressor on? I do have VCDS but not sure of the process. I have noticed that on the measured block the compressor relay will switch to off and the compressor will continue to run.
  12. Air suspension, compressor won't shut off!

    Brakes, Steering, Suspension, Wheels and Tires
    Thanks guys. However, I have a question regarding the relay. When I tested the relay, I removed it, placed 12 V across terminals 85 and 86(I believe). I verified that I heard the click and the connections between terminal 30 and 87 when from infinite resistance to continuity. Additionally, once...
  13. Air suspension, compressor won't shut off!

    Brakes, Steering, Suspension, Wheels and Tires
    Hi All, Apologies if the answer is here somewhere but I haven't been able to find it yet. Anyway, I've been working on getting my air suspension working properly again. Currently, it appears that the compressor won't shut off, I think from the high pressure switch? Here's the list of events so...
  14. Solution for Replace factory NAVI system

    Commercial Posts
    Hi Allen, can you give what the current best selection is for the above mentioned vehicle? I would also be interested in the backup camera and any discount you are giving to clubtouareg members. Thanks in advance. FYI, I have Samsung phones if that makes any difference for connecting. p.s...
  15. 07 V10 Rear Camera mixing

    General Maintenance & Repair
    Hello, I am researching adding a backup camera to a 2007 V10 Touareg, and can't seem to find an answer to my idea on implementing this. What I am considering is the following: 1. Using the VW handle for the camera. 2. Using the VW camera as I believe it is necessary for the controller input...
  16. V10 aircon compressor removal

    General Maintenance & Repair
    That's cool. I think I'm replacing the compressor as well. Any tips on how you got that driveshaft extension piece removed from the old unit? Mine seems pretty tight.
  17. Airconditioner Issues

    General Maintenance & Repair
    Hi Fusca, I haven't heard of the PCV on the Touareg, but there is the RCV, which I mentioned on the last reply which is connected to the compressor. If you replaced the compressor, I would think you had a new RCV valve as well. Before you tried to add the freon, did you pull a vacuum on the...
  18. Airconditioner Issues

    General Maintenance & Repair
    The Touareg doesn't have a pressure switch but there is a pressure sender, that monitors the pressure on the high side of the system. I believe it is located between the high pressure service port and the front expansion valve. Also, the Touareg doesn't use the traditional "clutch" driven...
  19. V10 aircon compressor removal

    General Maintenance & Repair
    Did you happen to replace the freehub too when you replaced the compressor? I notice that my belt is pretty loose on the drive side, an will be replacing it. Not sure if I should do the freehub as well, I see it is mentioned as a service item but not sure if it needs replacing or if it's just a...
  20. Solution for Replace factory NAVI system

    Commercial Posts
    Thanks Allen. Would you be able to tell me if the multiple antenna support, and the cd changer still function with this setup? Thanks for the help.
1-20 of 34 Results
Top