Club Touareg Forum banner
Cancel
Create thread New Garage Forums

Adblue Issues again as expected- More adventures coming...

Jump to Latest
41 - 60 of 81 Posts
#41 · (Edited)
alfissimo said:
(remember I asked about the .98 not being at 1.00, you said it was fine)
Click to expand...
Absolutely NOT. I was actually LOLing at this $hitfest

Let me try to break it down for you again.
IF or WHEN you reset the LTA and it goes to\or near the baseline of 1.00, you need to go drive 50mi until the system relearns and calibrates.
IF after all that it's still in the acceptable range, you won't get a MIL related to THAT (note that NOx code is separate)

So what needed to happen, in the following order, was
  • reset LTA and death countdown (you did)
  • check\validate that LTA is near baseline (you did)
  • go drive 50 miles (you did)
  • IF no MIL returns, re-check LTA to ensure that it is still in range (you were going to do, but instead reported MIL return)
  • if LTA is good, carry on with life (you saw it was NFG and went rogue.... decided to just reset it gain)
  • If LTA is NFG, figure out why (this is when you pull and clean the injector, and\or run output tests and measure what it delivers, etc)

So, now that you've cleaned the injector, it's feasible that this will allow correct DEF delivery.
In order to validate this, you need to start with the LTA in range (or at baseline), and without codes.
Drive 50 miles, check LTA again.
Based on findings, see above for "next steps".

Image
 
Discussion starter · #42 ·
TouaregRoadie said:
My 2016 is currently in the midst of a similar problem. Has been at two dealers for most of the past 3 weeks. Replaced ad blu heater (2nd time). The next week the CEL light went off. Off to another dealer who have replaced Nox sensors and catalysts. There is apparently an entire ordeal they have to go through to get the codes from firing once this is all done.
Click to expand...
Yes, this is why I am trying to do it myself first so I don't have to spend 3 weeks with no car.
 
Discussion starter · #43 ·
SaVAGeSoot said:
Absolutely NOT. I was actually LOLing at this $hitfest

Let me try to break it down for you again.
IF or WHEN you reset the LTA and it goes to\or near the baseline of 1.00, you need to go drive 50mi until the system relearns and calibrates.
IF after all that it's still in the acceptable range, you won't get a MIL related to THAT (note that NOx code is separate)

So what needed to happen, in the following order, was
  • reset LTA and death countdown (you did)
  • check\validate that LTA is near baseline (you did)
  • go drive 50 miles (you did)
  • IF no MIL returns, re-check LTA to ensure that it is still in range (you were going to do, but instead reported MIL return)
  • if LTA is good, carry on with life (you saw it was NFG and went rogue.... decided to just reset it gain)
  • If LTA is NFG, figure out why (this is when you pull and clean the injector, and\or run output tests and measure what it delivers, etc)

So, now that you've cleaned the injector, it's feasible that this will allow correct DEF delivery.
In order to validate this, you need to start with the LTA in range (or at baseline), and without codes.
Drive 50 miles, check LTA again.
Based on findings, see above for "next steps".
Click to expand...
Anyway, after over 50 miles clocked. LTA was checked @1.08. Then drove 20+ more miles and checked it again @1.06

No Cel or Countdown.

If it returns, It will go to the dealer to have them replace parts for now or if I can I will run the Output test on injector.
 
#44 ·
alfissimo said:
Yes, this is why I am trying to do it myself first so I don't have to spend 3 weeks with no car.
Click to expand...
Luckily for me it happened around a couple work trips, then I got a loaner from the dealer. So all is not lost. Just makes me nervous for the future.

I really feel like part of the problem is so many of these dealer techs are in their early 20's and haven't really seen many of the TDIs.
 
Discussion starter · #45 ·
TouaregRoadie said:
Luckily for me it happened around a couple work trips, then I got a loaner from the dealer. So all is not lost. Just makes me nervous for the future.

I really feel like part of the problem is so many of these dealer techs are in their early 20's and haven't really seen many of the TDIs.
Click to expand...
This is the problem and VW trying to go full electric. Many techs are way way too young now and have no experience with these cars. If you are lucky, you will have techs with experience and service advisors that have been through these cars too. My dealer that I ditched for a moment has this experience and techs that have worked on Touaregs but it's mostly for easy stuff. Timing chain they will refer me to another dealer with more experience.
 
#47 ·
I'm replacing NOx sensor B1S1 for consistent reading of -100ppm. I'm uncertain how to reset the Long Adaptation of Dosing of DEF. I understand I'd like it to be 1, but just getting some experience w programming w VCDS and worry about killing the ECM. I am out of both warranties (reg and diesegate), so don't have the luxury of waiting for the stealershipto forget it for free as they did for Savagesoot.
Thanx.
 
#51 ·
SaVAGeSoot said:
Irrelevant..... VCDS saved it.
Click to expand...
After searching my laptop memory found my scans.
This all occurred within a week of adding AdBlue because I received the AdBlue low light.
After the first scan I removed my DEF injector- it was squeeky clean, no crystals at all. Thinking this was just related to an AdBlue volume reset error and seeing a volume of 80% now registered, I cleared the code hoping for the best. Unfortunately, the CEL returned in about a week, with the second scan at this point.
I now pulled the NOx sensor finding cover in soot which I cleaned with SeaFoam with a significant amt of debris cleared from inside the holes on the sensor [able to see in the SeaFoam]. After replacing the sensor, test drove my girl, graphing the NOx concentrations up and downstream. Up were about 1200, down 10-30ppm as I recall. Unfortunately didn't save the graph, but recall the values were roughly 100/1. Thought it was fixed, cleared the codes. Alas, the CEL back after 50mi driving. This time removed the NOx sensor again to find it badly fouled with soot again. Recleaned and reinstalled, but also read the intake manifold can get badly obstructed with soot, which it was; I couldn't see the opening for the exhaust gas. Figured this might be why the sensor became fouled so quickly, so cleaned that, cleared the codes and test drove graphing the NOx concentrations again. This time the up sensor read -100ppm thruout, never varying. Checked the conections for the sensor but couldn't find anything amiss so ordered a new sensor. I did see a thread about reseting the Long Adaptation of Dosing for DEF after replacing a NOx sensor. And so my sensor arrives today and I'm hoping to be set to do that adaptation if someone can guide me thru the process. I believe that covers it.
If I might add, consider checking the opening of the exhaust gas recirculation line into the intake manifold if you're over 100k mi, mine was really plugged up.
 

Attachments

#52 ·
I refuse to keep downloading everyone's scans onto my devices because they are too lazy to learn how to use code wrap.
Please post in code wrap. There's even a "clickable" insert built into the forum UI.... I don't know why everyone struggles so much with this.
 
#53 ·
Not lazy, unaware. I've searched "code wrap" and got zilch that helped. Do I type "code wrap" then paste the scan? When I did that and previewed, I got only what I typed. By clickable 'insert' do you mean like loading a picture?
I'm willing and trying to expand my understanding of different technologies, not the least VCDS. I get having the scans in the displayed format makes them easier to review, but code wrap isn't described anywhere in the FYI or welcome areas.
 
#54 ·
TTreg said:
Not lazy, unaware. I've searched "code wrap" and got zilch that helped. Do I type "code wrap" then paste the scan? When I did that and previewed, I got only what I typed. By clickable 'insert' do you mean like loading a picture?
I'm willing and trying to expand my understanding of different technologies, not the least VCDS. I get having the scans in the displayed format makes them easier to review, but code wrap isn't described anywhere in the FYI or welcome areas.
Click to expand...
On the box that you type a reply in, look for the three dots next to the smiley face. Hit it and look at the drop down - there is a code tag in the list. Hit it and a box opens. Paste your scan into that and hit Continue. It should look nice and a be a small box that we can scroll inside without it taking up a large portion of the page. Do that for each scan.

For forums without that feature, use this but with the square brackets []: (code)text pasted in(/code).
 
  • Helpful
Reactions: TTreg
Save
Reply Quote Like Like
#55 ·
Thanks C-Ya.
A little instruction goes a long way.
As requested: code wrap.

Code: 
Wednesday,03,January,2024,08:11:26:03209
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 23.11.0.0 (x64)  HEX-V2 CB: 0.4643.4
Data version: 20231027 DS351.0
www.Ross-Tech.com


VIN: WVGFK9BP5CD004508   License Plate:


Chassis Type: BP-VW52 (7P6)
Scan: 01 02 03 05 08 09 10 15 16 17 19 36 42 46 52 53 55 56 5F 62
          65 69 6D 72

VIN: WVGFK9BP5CD004508   Mileage: 221648km-137725miles

01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
69-Trailer -- Status: OK 0000
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CATA)       Labels:. 059-907-401-V2.clb
   Part No SW: 7P0 907 401 J    HW: 7P0 907 401 E
   Component: 3.0TDI FSA    H17 0008 
   Revision: 56H17---    CVN: 66FD96005C3E0D045C3E0D04
   Coding: 292A4012233600050000
   Shop #: WSC 02420 444 00000
   ASAM Dataset: EV_ECM30TDI0117P0907401J 002007
   ROD: EV_ECM30TDI0117P0907401J_002.rod
   VCID: 36362F3638C7B52AC5F-8062
   VINID: 9E65D66C94A0153500004140208E0C5FFE

3 Faults Found:
9954 - NOx Reductant Consumption too Low
          P20F4 00 [10101111] - -
          MIL ON - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 221603 km
                    Date: 2023.12.30
                    Time: 14:51:00

                    Engine RPM: 1811.00 /min
                    Normed load value: 91.0 %
                    Vehicle speed: 110 km/h
                    Coolant temperature: 89 °C
                    Intake air temperature: 21 °C
                    Ambient air pressure: 970 mbar
                    Voltage terminal 30: 14.420 V
                    Unlearning counter according OBD: 40
                    Long-term adaptation of reduction agent dosage: 1.81
                    Measured NOx conversion range 1: 0.000
                    Efficiency threshold of NOx conversion range 1: 0.000
                    Mean temperature of SCR catalyst: 360.9 °C
                    NOx sensor 1: NOx concentration: 130 ppm
                    NOx sensor 2: NOx concentration: 56 ppm

9953 - Reductant Quality Performance
          P207F 00 [11101101] - -
          MIL ON - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 221603 km
                    Date: 2023.12.30
                    Time: 14:51:00

                    Engine RPM: 1814.50 /min
                    Normed load value: 91.0 %
                    Vehicle speed: 110 km/h
                    Coolant temperature: 89 °C
                    Intake air temperature: 21 °C
                    Ambient air pressure: 970 mbar
                    Voltage terminal 30: 14.440 V
                    Unlearning counter according OBD: 40
                    Long-term adaptation of reduction agent dosage: 1.81
                    Measured NOx conversion range 1: 0.000
                    Efficiency threshold of NOx conversion range 1: 0.000
                    Mean temperature of SCR catalyst: 360.6 °C
                    NOx sensor 1: NOx concentration: 128 ppm
                    NOx sensor 2: NOx concentration: 56 ppm

8863 - Particulate Filter
          P2459 00 [01100000] - Regeneration Frequency
          Intermittent - Not Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 220399 km
                    Date: 2023.11.24
                    Time: 14:30:45

                    Engine RPM: 1370.50 /min
                    Normed load value: 0.0 %
                    Vehicle speed: 69 km/h
                    Coolant temperature: 87 °C
                    Intake air temperature: 25 °C
                    Ambient air pressure: 960 mbar
                    Voltage terminal 30: 14.820 V
                    Unlearning counter according OBD: 7
                    Exhaust gas jet volume in particle filter: 177.4 mł/h
                    Particle filter: difference pressure: 68 hPa
                    Particle filter: soot mass measured: 25.92 g
                    Particle filter: soot mass calculated: 12.51 g
                    Exhaust gas temperature sensor 3: 307.5 °C
                    Exhaust gas temperature sensor 4: 241.9 °C

Readiness: 1 2 0 0 0

-------------------------------------------------------------------------------
Address 02: Auto Trans (J217)       Labels:| 0C8-927-7XX-V1.clb
   Part No SW: 0C8 927 750 G    HW: 0C8 927 750 G
   Component: AL1000 AISIN  001 3407 
   Serial number:                CVN: CB5A7D50
   Coding: 001368
   Shop #: WSC 99999 999 83333
   ASAM Dataset: EV_TCMAL991031 002112
   ROD: EV_TCMAL991031_002_VW52.rod
   VCID: 303A192EDAA39B1A9F3-8064

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:* 7P0-907-379.clb
   Part No SW: 7P0 907 379 K    HW: 7P0 907 379 A
   Component: MK25A         H36 0418 
   Revision: --------    Serial number: 424510010EC010 Dataset Number: 7P0012v____ 7P13
   Coding: 5B7613C349242557DAF9C89392DAA4407700
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_MK25AXT 007001
   ROD: EV_ESPMK25A00700.rod
   VCID: 45D458FA75212EB25C5-8010

No fault code found.

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393)       Labels:. 8K0-907-064-05.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H31 0330 
   Revision: 00002001   
   Coding: 09860000000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B0D6226BB5E002221-8026

   Subsystem 1 - Part No SW: 7P6 959 754 M    HW: 7P6 959 754 M
   Component: FBSTOUAREGIDG  H04 0051
   Serial number: 0511000043481016   

   Subsystem 2 - Part No SW: 4H0 905 852 B    HW: 4H0 905 852 B
   Component: J764 ELV MLB  H38 0044
   Serial number: 2311000200602009   

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels:| 7P6-907-040.clb
   Part No SW: 7P6 907 040 BA    HW: 7P6 907 040 BA
   Component: Klima 2 Zonen H20 1203 
   Coding: B606200A80
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirCondiFront 004001
   ROD: EV_AirCondiFront_VW52.rod
   VCID: 74B2D53E6E3BE73A3BB-8020

1 Fault Found:
0243 - Function Restriction due to Faults in Other Modules
          U1113 00 [00001000] - -
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 79
                    Mileage: 220555 km
                    Date: 2023.11.29
                    Time: 19:53:25


-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 4H0-907-063-V1.clb
   Part No SW: 4H0 907 063 BD    HW: 4H0 907 063 D
   Component: BCM1 2.0      H12 0100 
   Revision: 15012002    Serial number: 00000001066813
   Coding: 26001012973C5D010020180300005D0C431C660882010261000000020000
   Shop #: WSC 31414 790 00001
   VCID: 6B80CE42338538C2EA1-803E

   Subsystem 1 - Part No SW: 7P0 955 119     HW: 7P0 955 119   Labels: 1KX-955-119.CLB
   Component: WWS    110902  31  0020
   Serial number: 90243400110926160012
   Coding: 004DBD

   Subsystem 2 - Part No SW: 7P0 955 559 D    HW: 7P0 955 559 D  Labels: 8K0-955-559.CLB
   Component: RLFS  H09 0011
   Serial number: 10242899           
   Coding: 025223

   Subsystem 3 - Part No SW: 7P6 941 431 E    HW: 7P6 941 431 E
   Component: E1 - LDS  H04 0031
   Serial number: 00000000000110110522

   Subsystem 4 - Part No SW: 4H0 907 410 A    HW: 4H0 907 410 A
   Component: USHL4.2  H30 0020
   Serial number: 0000001805569R0R9P07

No fault code found.

-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446)       Labels:| 7P6-919-475.clb
   Part No SW: 7P6 919 475 B    HW: 7N0 919 475
   Component: PARKHILFE 8K  H05 0021 
   Revision: --------    Serial number: 28261125001318
   Coding: 110501
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_VW526ParkiAssis2 001011
   ROD: EV_VW526ParkiAssis2.rod
   VCID: 42DE43E6640F198A797-8016

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels:| 7P0-959-655.clb
   Part No SW: 7P0 959 655 C    HW: 7P0 959 655 C
   Component: VW10Airbag025 H05 0025 
   Revision: --------    Serial number: 003L00000KBC Dataset Number: 7P6003v____ 0983
   Coding: 000000000000000000000000000000003235
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirbaVW10BPAVW526 001001
   ROD: EV_AirbaVW10BPAVW526_001.rod
   VCID: 41DC4CEA6109029260D-8014

   Seat occupied recognition:
   Subsystem 1 - Part No SW: 7P6 959 339     HW: 7P6 959 339
   Component: BF-Gewichtss.  003 0005
   Serial number: 5850000R1162204ZKZ

   Crash sensor for side airbag: driver side:
   Serial number: 3575LRB405B0KREU7GSQ

   Front Passenger's Side Airbag Crash Sensor:
   Serial number: 3585LRB40590KREUE0B%

   Rear Side Airbag Crash Sensor (on driver's side):
   Serial number: 3515RRB405L0MFP63GQ7

   Passenger side rear thorax airbag crash sensor:
   Serial number: 3525RRB405H0MFP6C8N2

   Crash sensor for front airbag: driver side:
   Serial number: 3555NRB405B0JL5I48RT

   Crash sensor for front airbag: front passenger side:
   Serial number: 3565NRB405D0JL5I91AD

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527)       Labels:. 4H0-953-568.clb
   Part No SW: 4H0 953 568 F    HW: 7P6 953 507 L
   Component: Lenks.Modul   H03 0005 
   Revision: --------    Serial number: 90815KIT0003K
   Coding: 000015
   Shop #: WSC 31414 790 00001
   VCID: 36362F363847B52AC5F-8062

   Subsystem 1 - Part No SW: 7P6 959 542     HW: 7P6 959 542
   Component: E221__MFL-TAS  H03 0027
   Serial number: 0111221             

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 7P6-920-xxx-17.clb-SRI1
   Part No SW: 7P6 920 980 N    HW: 7P6 920 980 N
   Component: Kombi         H13 0239 
   Revision: 11240062    Serial number: 658280911592007
   Coding: 8B7733022B00CF05020004
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_KombiUDSRBVW526 001013
   ROD: EV_KombiUDSRBVW526.rod
   VCID: 47C852F24F2D3CA2AE9-8012

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:* None
   Part No SW: 7P6 907 530 C    HW: 7P6 907 530 A
   Component: GW-CAN-L-MOST H08 5202 
   Revision: --------    Serial number: 00000000257029
   Coding: 0001037500
   Shop #: WSC 31414 790 00001
   GVL: FB4F40451D7B000000
   ASAM Dataset: EV_GatewVW526UDS 001006
   ROD: EV_GatewUDS_VW52.rod
   VCID: 382A210E32D3435AD73-806C

   Battery Monitoring Control Module:
   Subsystem 1 - Part No SW: 7P0 915 181 A    HW: 7P0 915 181
   Component: Batt_Sensor  H07 0140
   Serial number: 40296422534191204774

No fault code found.

-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136)       Labels: None
   Part No SW: 4H0 959 760 D    HW: 4H0 959 760 D
   Component: MEM-FS        H08 0153 
   Revision: AA000000    Serial number: 00000013819972
   Coding: 0058130000004001000001010101202020202121202020
   Shop #: WSC 31414 790 00001
   VCID: 3432153E2E3BA73AFBB-8060

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:. 4H0-959-793.clb
   Part No SW: 4H0 959 793 N    HW: 4H0 959 793 F
   Component: TSG FA        H07 0166 
   Revision: --------    Serial number: 0000120203920
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 44D245FE7E9B17BA4BB-8010

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv. (J393)       Labels:. 4H0-907-064-46.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H31 0330 
   Revision: 00002001    Serial number: 0158646713   
   Coding: 0186123A28B9509480A00620210000000000000000000000000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B0D6226BB5E002221-8026

   Subsystem 1 - Part No SW: 7P6 959 719     HW: 7P6 959 719
   Component: GTO BT  H19 0058
   Serial number: 216111595           

   Subsystem 2 - Part No: 1K0 951 605 C
   Component: LIN BACKUP HO  H05 1501

   Subsystem 3 - Part No SW: 7P0 959 591     HW: 7P0 959 591
   Component: J245 PS30.050  H07 0006
   Serial number:     WOO1355042.     
   Coding: 191100

   Subsystem 4 - Part No SW: 7P0 959 591 A    HW: 4H0 959 591
   Component: J394 PS30.050  H07 0006
   Serial number:     WOO1360418/     
   Coding: 191100

1 Fault Found:
02202 - Trunk / Luggage Compartment Closing Assist; Position - Locked (F332)
            008 - Implausible Signal - Intermittent
             Freeze Frame:
                    Fault Status: 00101000
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 84
                    Mileage: 220759 km
                    Time Indication: 0
                    Date: 2023.12.03
                    Time: 14:37:42


-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:. 4H0-959-792.clb
   Part No SW: 4H0 959 792 F    HW: 4H0 959 792 F
   Component: TSG BF        H07 0166 
   Revision: --------    Serial number: 0000120323875
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 3B203E02036568423A1-806E

No fault code found.

-------------------------------------------------------------------------------
Address 53: Parking Brake (J540-)       Labels:| 7P0-907-801.clb
   Part No SW: 7P0 907 801 F    HW: 7P0 907 801 F
   Component: EPB           H51 1201 
   Revision: 00000000    Serial number: A1191100112    Dataset Number:             A001
   Coding: 01040200
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_ParkbA7 000006
   ROD: EV_ParkbA7.rod
   VCID: 36362F3638C7B52AC5F-8062

   Slave 3:

No fault code found.

-------------------------------------------------------------------------------
Address 55: Headlight Range (J745)       Labels:. 7P6-907-357.clb
   Part No SW: 7P6 907 357     HW: 7L6 907 357 C
   Component: AFS-ECU       H04 0110 
   Revision: --------    Serial number: -------------- Dataset Number: 7P0036v____ 0009
   Coding: 010A00010F000400
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeadlRegulVWAFS 005006
   ROD: EV_HeadlRegulVWAFS_VW52.rod
   VCID: 7CA2FD1E466BAF7A73B-8028

   Left_headlamp_power_output_stage:
   Subsystem 1 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo links  H01 0002
   Coding: 130000

   Right_headlamp_power_output_stage:
   Subsystem 2 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo rechts  H01 0002
   Coding: 130000

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (R)       Labels:. 4F0-035-0xx-56.clb
   Part No SW: 4G0 035 082 B    HW: 4G0 035 082
   Component: Radio U SIRIU H53 0076 
   Revision: AB001007    Serial number: 156I%0B7554931
   Coding: 020007020100000001
   Shop #: WSC 31414 790 00001
   VCID: 1F18EA92B7BD1462369-804A

No fault code found.

-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794)       Labels:. 4E0-035-6xx-5F.clb
   Part No SW: 7P6 035 664 B    HW: 7P6 035 664
   Component: H-BN-NA       H44 0319 
   Revision: --------    Serial number: 445I20B7520788
   Coding: 010200050040E1ED41022B0E00000003F0000101
   Shop #: WSC 31414 790 00001
   VCID: 372822323F4D4C22DE9-8062

   Subsystem 1 - Part No: 8R0 060 884 AC
   Component: NAR 2011  0503

   Subsystem 2 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9L79004CE     

   Subsystem 3 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9L79004CE     

   Subsystem 4 - Part No: 8R0 060 961
   Component: CD-Database  1886

No fault code found.

-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HL        H09 0167 
   Revision: --------    Serial number: 0000120197821
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2E3B060C5F514A217-806E

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502)       Labels: 3Y0-907-273.clb
   Part No SW: 7P6 907 273 F    HW: 7P6 907 273 F
   Component: RDKBERU25     H09 0008 
   Serial number: 10000000045970 Dataset Number: 7P6096v____ 0017
   ASAM Dataset: EV_RDKBERU25 003006
   ROD: EV_RDKBERU25_VW52.rod
   VCID: 3FD84A1217FD7462169-806A

No fault code found.

-------------------------------------------------------------------------------
Address 69: Trailer (J345)       Labels: Redir Fail!
   Part No SW: 7P0 907 383 F    HW: 7P0 907 383 B
   Component: Anhaenger     H09 0110 
   Revision: 5A001001    Serial number: 00000157631323
   Coding: 020D000000000000
   Shop #: WSC 31414 790 00001
   VCID: 3B203E02036568423A1-806E

No fault code found.

-------------------------------------------------------------------------------
Address 6D: Trunk Elect. (----)       Labels:| 7N0-959-107.clb
   Part No SW: 7P6 959 107 A    HW: 7P6 959 107
   Component: HDSG-Modul    H10 0620 
   Revision: 22010001    Serial number: 258100389 Dataset Number: 7P6959107A  D043
   Coding: 0533314003
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeckkTouar 202137
   ROD: EV_HeckkTouar.rod
   VCID: 3D24301A1DF16672045-8068

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HR        H09 0167 
   Revision: --------    Serial number: 0000120196514
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2E3B060C5F514A217-806E

No fault code found.

End----------(Elapsed Time: 02:05, VBatt start/end: 12.1V/12.1V)-----------
Code: 
Saturday,13,January,2024,10:15:55:03209
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 23.11.0.0 (x64)  HEX-V2 CB: 0.4643.4
Data version: 20231027 DS351.0
www.Ross-Tech.com


VIN: WVGFK9BP5CD004508   License Plate:


Chassis Type: BP-VW52 (7P6)
Scan: 01 02 03 05 08 09 10 15 16 17 19 36 42 46 52 53 55 56 5F 62
          65 69 6D 72

VIN: WVGFK9BP5CD004508   Mileage: 221933km-137902miles

01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
69-Trailer -- Status: OK 0000
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CATA)       Labels:. 059-907-401-V2.clb
   Part No SW: 7P0 907 401 J    HW: 7P0 907 401 E
   Component: 3.0TDI FSA    H17 0008 
   Revision: 56H17---    CVN: 66FD96005C3E0D045C3E0D04
   Coding: 292A4012233600050000
   Shop #: WSC 02420 444 00000
   ASAM Dataset: EV_ECM30TDI0117P0907401J 002007
   ROD: EV_ECM30TDI0117P0907401J_002.rod
   VCID: 36362F3638C7B52AC5F-8062
   VINID: 9E65D66C94A0153500004140208E0C5FFE

1 Fault Found:
17277 - SCR NOx Catalyst Bank 1
          P20EE 00 [11101000] - Efficiency too Low
          MIL ON - Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 221794 km
                    Date: 2024.01.08
                    Time: 08:05:14

                    Engine RPM: 1366.50 /min
                    Normed load value: 0.0 %
                    Vehicle speed: 57 km/h
                    Coolant temperature: 73 °C
                    Intake air temperature: 6 °C
                    Ambient air pressure: 960 mbar
                    Voltage terminal 30: 14.720 V
                    Unlearning counter according OBD: 40
                    Accelerator pedal travel: 0.00 %
                    Accelerator pedal: sensor voltage 1: 742.6 mV
                    Accelerator pedal: sensor voltage 2: 371.2 mV
                    Accelerator pedal: switch positions-Bits 0-7: 8
                    Starter control: Interlock- or P/N-signal-Bits 0-7: 0
                    Limitation: torque: 141.4 Nm
                    Control Module temperature: 14.7 °C

Readiness: 1 1 0 1 0

-------------------------------------------------------------------------------
Address 02: Auto Trans (J217)       Labels:| 0C8-927-7XX-V1.clb
   Part No SW: 0C8 927 750 G    HW: 0C8 927 750 G
   Component: AL1000 AISIN  001 3407 
   Serial number:                CVN: CB5A7D50
   Coding: 001368
   Shop #: WSC 99999 999 83333
   ASAM Dataset: EV_TCMAL991031 002112
   ROD: EV_TCMAL991031_002_VW52.rod
   VCID: 303A192EDAA39B1A9F3-8064

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:* 7P0-907-379.clb
   Part No SW: 7P0 907 379 K    HW: 7P0 907 379 A
   Component: MK25A         H36 0418 
   Revision: --------    Serial number: 424510010EC010 Dataset Number: 7P0012v____ 7P13
   Coding: 5B7613C349242557DAF9C89392DAA4407700
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_MK25AXT 007001
   ROD: EV_ESPMK25A00700.rod
   VCID: 45D458FA75212EB25C5-8010

No fault code found.

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393)       Labels:. 8K0-907-064-05.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H31 0330 
   Revision: 00002001   
   Coding: 09860000000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B0D6226BB5E002221-8026

   Subsystem 1 - Part No SW: 7P6 959 754 M    HW: 7P6 959 754 M
   Component: FBSTOUAREGIDG  H04 0051
   Serial number: 0511000041651010   

   Subsystem 2 - Part No SW: 4H0 905 852 B    HW: 4H0 905 852 B
   Component: J764 ELV MLB  H38 0044
   Serial number: 2311000200602009   

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels:| 7P6-907-040.clb
   Part No SW: 7P6 907 040 BA    HW: 7P6 907 040 BA
   Component: Klima 2 Zonen H20 1203 
   Coding: B606200A80
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirCondiFront 004001
   ROD: EV_AirCondiFront_VW52.rod
   VCID: 74B2D53E6E3BE73A3BB-8020

1 Fault Found:
0243 - Function Restriction due to Faults in Other Modules
          U1113 00 [00001000] - -
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Priority: 6
                    Fault Frequency: 6
                    Reset counter: 126
                    Mileage: 221696 km
                    Date: 2024.01.03
                    Time: 18:03:16


-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 4H0-907-063-V1.clb
   Part No SW: 4H0 907 063 BD    HW: 4H0 907 063 D
   Component: BCM1 2.0      H12 0100 
   Revision: 15012002    Serial number: 00000001066813
   Coding: 26001012973C5D010020180300005D0C431C660882010261000000020000
   Shop #: WSC 31414 790 00001
   VCID: 6B80CE42338538C2EA1-803E

   Subsystem 1 - Part No SW: 7P0 955 119     HW: 7P0 955 119   Labels: 1KX-955-119.CLB
   Component: WWS    110902  31  0020
   Serial number: 90243400110926160012
   Coding: 004DBD

   Subsystem 2 - Part No SW: 7P0 955 559 D    HW: 7P0 955 559 D  Labels: 8K0-955-559.CLB
   Component: RLFS  H09 0011
   Serial number: 10242899           
   Coding: 025223

   Subsystem 3 - Part No SW: 7P6 941 431 E    HW: 7P6 941 431 E
   Component: E1 - LDS  H04 0031
   Serial number: 00000000000110110522

   Subsystem 4 - Part No SW: 4H0 907 410 A    HW: 4H0 907 410 A
   Component: USHL4.2  H30 0020
   Serial number: 0000001805569R0R9P07

No fault code found.

-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446)       Labels:| 7P6-919-475.clb
   Part No SW: 7P6 919 475 B    HW: 7N0 919 475
   Component: PARKHILFE 8K  H05 0021 
   Revision: --------    Serial number: 28261125001318
   Coding: 110501
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_VW526ParkiAssis2 001011
   ROD: EV_VW526ParkiAssis2.rod
   VCID: 42DE43E6640F198A797-8016

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels:| 7P0-959-655.clb
   Part No SW: 7P0 959 655 C    HW: 7P0 959 655 C
   Component: VW10Airbag025 H05 0025 
   Revision: --------    Serial number: 003L00000KBC Dataset Number: 7P6003v____ 0983
   Coding: 000000000000000000000000000000003235
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirbaVW10BPAVW526 001001
   ROD: EV_AirbaVW10BPAVW526_001.rod
   VCID: 41DC4CEA6109029260D-8014

   Seat occupied recognition:
   Subsystem 1 - Part No SW: 7P6 959 339     HW: 7P6 959 339
   Component: BF-Gewichtss.  003 0005
   Serial number: 5850000R1162204ZKZ

   Crash sensor for side airbag: driver side:
   Serial number: 3575LRB405B0KREU7GSQ

   Front Passenger's Side Airbag Crash Sensor:
   Serial number: 3585LRB40590KREUE0B%

   Rear Side Airbag Crash Sensor (on driver's side):
   Serial number: 3515RRB405L0MFP63GQ7

   Passenger side rear thorax airbag crash sensor:
   Serial number: 3525RRB405H0MFP6C8N2

   Crash sensor for front airbag: driver side:
   Serial number: 3555NRB405B0JL5I48RT

   Crash sensor for front airbag: front passenger side:
   Serial number: 3565NRB405D0JL5I91AD

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527)       Labels:. 4H0-953-568.clb
   Part No SW: 4H0 953 568 F    HW: 7P6 953 507 L
   Component: Lenks.Modul   H03 0005 
   Revision: --------    Serial number: 90815KIT0003K
   Coding: 000015
   Shop #: WSC 31414 790 00001
   VCID: 36362F363847B52AC5F-8062

   Subsystem 1 - Part No SW: 7P6 959 542     HW: 7P6 959 542
   Component: E221__MFL-TAS  H03 0027
   Serial number: 0111221             

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 7P6-920-xxx-17.clb-SRI1
   Part No SW: 7P6 920 980 N    HW: 7P6 920 980 N
   Component: Kombi         H13 0239 
   Revision: 11240062    Serial number: 658280911592007
   Coding: 8B7733022B00CF05020004
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_KombiUDSRBVW526 001013
   ROD: EV_KombiUDSRBVW526.rod
   VCID: 47C852F24F2D3CA2AE9-8012

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:* None
   Part No SW: 7P6 907 530 C    HW: 7P6 907 530 A
   Component: GW-CAN-L-MOST H08 5202 
   Revision: --------    Serial number: 00000000257029
   Coding: 0001037500
   Shop #: WSC 31414 790 00001
   GVL: FB4F40451D7B000000
   ASAM Dataset: EV_GatewVW526UDS 001006
   ROD: EV_GatewUDS_VW52.rod
   VCID: 382A210E32D3435AD73-806C

   Battery Monitoring Control Module:
   Subsystem 1 - Part No SW: 7P0 915 181 A    HW: 7P0 915 181
   Component: Batt_Sensor  H07 0140
   Serial number: 40296422534191204774

No fault code found.

-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136)       Labels: None
   Part No SW: 4H0 959 760 D    HW: 4H0 959 760 D
   Component: MEM-FS        H08 0153 
   Revision: AA000000    Serial number: 00000013819972
   Coding: 0058130000004001000001010101202020202121202020
   Shop #: WSC 31414 790 00001
   VCID: 3432153E2E3BA73AFBB-8060

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:. 4H0-959-793.clb
   Part No SW: 4H0 959 793 N    HW: 4H0 959 793 F
   Component: TSG FA        H07 0166 
   Revision: --------    Serial number: 0000120203920
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 44D245FE7E9B17BA4BB-8010

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv. (J393)       Labels:. 4H0-907-064-46.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H31 0330 
   Revision: 00002001    Serial number: 0158646713   
   Coding: 0186123A28B9509480A00620210000000000000000000000000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B0D6226BB5E002221-8026

   Subsystem 1 - Part No SW: 7P6 959 719     HW: 7P6 959 719
   Component: GTO BT  H19 0058
   Serial number: 216111595           

   Subsystem 2 - Part No: 1K0 951 605 C
   Component: LIN BACKUP HO  H05 1501

   Subsystem 3 - Part No SW: 7P0 959 591     HW: 7P0 959 591
   Component: J245 PS30.050  H07 0006
   Serial number:     WOO1355042.     
   Coding: 191100

   Subsystem 4 - Part No SW: 7P0 959 591 A    HW: 4H0 959 591
   Component: J394 PS30.050  H07 0006
   Serial number:     WOO1360418/     
   Coding: 191100

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:. 4H0-959-792.clb
   Part No SW: 4H0 959 792 F    HW: 4H0 959 792 F
   Component: TSG BF        H07 0166 
   Revision: --------    Serial number: 0000120323875
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 3B203E02036568423A1-806E

No fault code found.

-------------------------------------------------------------------------------
Address 53: Parking Brake (J540-)       Labels:| 7P0-907-801.clb
   Part No SW: 7P0 907 801 F    HW: 7P0 907 801 F
   Component: EPB           H51 1201 
   Revision: 00000000    Serial number: A1191100112    Dataset Number:             A001
   Coding: 01040200
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_ParkbA7 000006
   ROD: EV_ParkbA7.rod
   VCID: 36362F3638C7B52AC5F-8062

   Slave 3:

No fault code found.

-------------------------------------------------------------------------------
Address 55: Headlight Range (J745)       Labels:. 7P6-907-357.clb
   Part No SW: 7P6 907 357     HW: 7L6 907 357 C
   Component: AFS-ECU       H04 0110 
   Revision: --------    Serial number: -------------- Dataset Number: 7P0036v____ 0009
   Coding: 010A00010F000400
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeadlRegulVWAFS 005006
   ROD: EV_HeadlRegulVWAFS_VW52.rod
   VCID: 7CA2FD1E466BAF7A73B-8028

   Left_headlamp_power_output_stage:
   Subsystem 1 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo links  H01 0002
   Coding: 130000

   Right_headlamp_power_output_stage:
   Subsystem 2 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo rechts  H01 0002
   Coding: 130000

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (R)       Labels:. 4F0-035-0xx-56.clb
   Part No SW: 4G0 035 082 B    HW: 4G0 035 082
   Component: Radio U SIRIU H53 0076 
   Revision: AB001007    Serial number: 156I%0B7554931
   Coding: 020007020100000001
   Shop #: WSC 31414 790 00001
   VCID: 1F18EA92B7BD1462369-804A

No fault code found.

-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794)       Labels:. 4E0-035-6xx-5F.clb
   Part No SW: 7P6 035 664 B    HW: 7P6 035 664
   Component: H-BN-NA       H44 0319 
   Revision: --------    Serial number: 445I20B7520788
   Coding: 010200050040E1ED41022B0E00000003F0000101
   Shop #: WSC 31414 790 00001
   VCID: 372822323F4D4C22DE9-8062

   Subsystem 1 - Part No: 8R0 060 884 AC
   Component: NAR 2011  0503

   Subsystem 2 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9L79004CE     

   Subsystem 3 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9L79004CE     

   Subsystem 4 - Part No: 8R0 060 961
   Component: CD-Database  1886

No fault code found.

-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HL        H09 0167 
   Revision: --------    Serial number: 0000120197821
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2E3B060C5F514A217-806E

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502)       Labels: 3Y0-907-273.clb
   Part No SW: 7P6 907 273 F    HW: 7P6 907 273 F
   Component: RDKBERU25     H09 0008 
   Serial number: 10000000045970 Dataset Number: 7P6096v____ 0017
   ASAM Dataset: EV_RDKBERU25 003006
   ROD: EV_RDKBERU25_VW52.rod
   VCID: 3FD84A1217FD7462169-806A

No fault code found.

-------------------------------------------------------------------------------
Address 69: Trailer (J345)       Labels: Redir Fail!
   Part No SW: 7P0 907 383 F    HW: 7P0 907 383 B
   Component: Anhaenger     H09 0110 
   Revision: 5A001001    Serial number: 00000157631323
   Coding: 020D000000000000
   Shop #: WSC 31414 790 00001
   VCID: 3B203E02036568423A1-806E

No fault code found.

-------------------------------------------------------------------------------
Address 6D: Trunk Elect. (----)       Labels:| 7N0-959-107.clb
   Part No SW: 7P6 959 107 A    HW: 7P6 959 107
   Component: HDSG-Modul    H10 0620 
   Revision: 22010001    Serial number: 258100389 Dataset Number: 7P6959107A  D043
   Coding: 0533314003
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeckkTouar 202137
   ROD: EV_HeckkTouar.rod
   VCID: 3D24301A1DF16672045-8068

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HR        H09 0167 
   Revision: --------    Serial number: 0000120196514
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2E3B060C5F514A217-806E

No fault code found.

End----------(Elapsed Time: 02:03, VBatt start/end: 12.0V/12.0V)-----------
 
#56 ·
Both those scans are outdated. I can give you input on whichever fault you want, but it's a crappy approach considering that you've already gone rogue and fixed/repaired/cleaned whatever, presumably driven a bunch of cycles/miles since, and have had other faults come up. You've also blown away all these codes and without having an exact understanding of when/why and what was done in what order, it leads to a crappy diagnostic approach.

My suggestion would be post a current scan and let's go from there in order to be the most efficient.

Let me know how you want to proceed. If new scan is not the way, tell me which one of the posted ones you want input on.
 
#57 ·
Gone rogue. Kinda like the sound a that; makes me sound all Luke Skywalker.
Keep in mind, I wasn't going thru this process with an eye to be presenting it for evaluation after the fact. I was simply trying to get my machine back to rolling as she should. I also realize I'm used to working with Rosie the Riveter, not a Prima Donna.
That said, here's the current scan.
I know diesels run dirty, but I was surprised the sensor was soot covered after 40-50mi in the exhaust gas. Is the exhaust gas that dirty normally?
Code: 
Saturday,09,March,2024,08:22:58:03209
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 23.11.0.0 (x64)  HEX-V2 CB: 0.4643.4
Data version: 20231027 DS351.0
www.Ross-Tech.com


VIN: WVGFK9BP5CD004508   License Plate:


Chassis Type: BP-VW52 (7P6)
Scan: 01 02 03 05 08 09 10 15 16 17 19 36 42 46 52 53 55 56 5F 62
          65 69 6D 72

VIN: WVGFK9BP5CD004508   Mileage: 222097km-138004miles

01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
69-Trailer -- Status: OK 0000
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CATA)       Labels:. 059-907-401-V2.clb
   Part No SW: 7P0 907 401 J    HW: 7P0 907 401 E
   Component: 3.0TDI FSA    H17 0008 
   Revision: 56H17---    CVN: 66FD96005C3E0D045C3E0D04
   Coding: 292A4012233600050000
   Shop #: WSC 02420 444 00000
   ASAM Dataset: EV_ECM30TDI0117P0907401J 002007
   ROD: EV_ECM30TDI0117P0907401J_002.rod
   VCID: 36362F3638C7B52AC5F-8062
   VINID: 9E65D66C94A0153500004140208E0C5FFE

1 Fault Found:
9879 - Sense Circuit for Heater for NOx Sensor 1 Bank 1
          P2209 00 [11101101] - Implausible Signal
          MIL ON - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 222086 km
                    Date: 2024.03.01
                    Time: 17:22:10

                    Engine RPM: 679.50 /min
                    Normed load value: 23.5 %
                    Vehicle speed: 0 km/h
                    Coolant temperature: 84 °C
                    Intake air temperature: 25 °C
                    Ambient air pressure: 950 mbar
                    Voltage terminal 30: 14.380 V
                    Unlearning counter according OBD: 40
                    NOx sensor 2: NOx concentration: 5 ppm
                    NOx sensor 1: NOx concentration: -100 ppm
                    Target value of heating temperature of NOx sensor 2-Bits 0-7: 1
                    NOx sensor 2: feed voltage: 14080 mV
                    NOx sensor 1: feed voltage: 14240 mV
                    Outside temperature: 21.5 °C
                    Mean injection quantity: 6.45 mg/stroke

Readiness: 1 1 0 1 0

-------------------------------------------------------------------------------
Address 02: Auto Trans (J217)       Labels:| 0C8-927-7XX-V1.clb
   Part No SW: 0C8 927 750 G    HW: 0C8 927 750 G
   Component: AL1000 AISIN  001 3407 
   Serial number:                CVN: CB5A7D50
   Coding: 001368
   Shop #: WSC 99999 999 83333
   ASAM Dataset: EV_TCMAL991031 002112
   ROD: EV_TCMAL991031_002_VW52.rod
   VCID: 303A192EDAA39B1A9F3-8064

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:* 7P0-907-379.clb
   Part No SW: 7P0 907 379 K    HW: 7P0 907 379 A
   Component: MK25A         H36 0418 
   Revision: --------    Serial number: 424510010EC010 Dataset Number: 7P0012v____ 7P13
   Coding: 5B7613C349242557DAF9C89392DAA4407700
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_MK25AXT 007001
   ROD: EV_ESPMK25A00700.rod
   VCID: 45D458FA75212EB25C5-8010

No fault code found.

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393)       Labels:. 8K0-907-064-05.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H31 0330 
   Revision: 00002001   
   Coding: 09860000000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B0D6226BB5E002221-8026

   Subsystem 1 - Part No SW: 7P6 959 754 M    HW: 7P6 959 754 M
   Component: FBSTOUAREGIDG  H04 0051
   Serial number: 0511000041651010   

   Subsystem 2 - Part No SW: 4H0 905 852 B    HW: 4H0 905 852 B
   Component: J764 ELV MLB  H38 0044
   Serial number: 2311000200602009   

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels:| 7P6-907-040.clb
   Part No SW: 7P6 907 040 BA    HW: 7P6 907 040 BA
   Component: Klima 2 Zonen H20 1203 
   Coding: B606200A80
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirCondiFront 004001
   ROD: EV_AirCondiFront_VW52.rod
   VCID: 74B2D53E6E3BE73A3BB-8020

1 Fault Found:
0243 - Function Restriction due to Faults in Other Modules
          U1113 00 [00001000] - -
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Priority: 6
                    Fault Frequency: 6
                    Reset counter: 126
                    Mileage: 221696 km
                    Date: 2024.01.03
                    Time: 18:03:16


-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 4H0-907-063-V1.clb
   Part No SW: 4H0 907 063 BD    HW: 4H0 907 063 D
   Component: BCM1 2.0      H12 0100 
   Revision: 15012002    Serial number: 00000001066813
   Coding: 26001012973C5D010020180300005D0C431C660882010261000000020000
   Shop #: WSC 31414 790 00001
   VCID: 6B80CE42338538C2EA1-803E

   Subsystem 1 - Part No SW: 7P0 955 119     HW: 7P0 955 119   Labels: 1KX-955-119.CLB
   Component: WWS    110902  31  0020
   Serial number: 90243400110926160012
   Coding: 004DBD

   Subsystem 2 - Part No SW: 7P0 955 559 D    HW: 7P0 955 559 D  Labels: 8K0-955-559.CLB
   Component: RLFS  H09 0011
   Serial number: 10242899           
   Coding: 025223

   Subsystem 3 - Part No SW: 7P6 941 431 E    HW: 7P6 941 431 E
   Component: E1 - LDS  H04 0031
   Serial number: 00000000000110110522

   Subsystem 4 - Part No SW: 4H0 907 410 A    HW: 4H0 907 410 A
   Component: USHL4.2  H30 0020
   Serial number: 0000001805569R0R9P07

No fault code found.

-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446)       Labels:| 7P6-919-475.clb
   Part No SW: 7P6 919 475 B    HW: 7N0 919 475
   Component: PARKHILFE 8K  H05 0021 
   Revision: --------    Serial number: 28261125001318
   Coding: 110501
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_VW526ParkiAssis2 001011
   ROD: EV_VW526ParkiAssis2.rod
   VCID: 42DE43E6640F198A797-8016

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels:| 7P0-959-655.clb
   Part No SW: 7P0 959 655 C    HW: 7P0 959 655 C
   Component: VW10Airbag025 H05 0025 
   Revision: --------    Serial number: 003L00000KBC Dataset Number: 7P6003v____ 0983
   Coding: 000000000000000000000000000000003235
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirbaVW10BPAVW526 001001
   ROD: EV_AirbaVW10BPAVW526_001.rod
   VCID: 41DC4CEA6109029260D-8014

   Seat occupied recognition:
   Subsystem 1 - Part No SW: 7P6 959 339     HW: 7P6 959 339
   Component: BF-Gewichtss.  003 0005
   Serial number: 5850000R1162204ZKZ

   Crash sensor for side airbag: driver side:
   Serial number: 3575LRB405B0KREU7GSQ

   Front Passenger's Side Airbag Crash Sensor:
   Serial number: 3585LRB40590KREUE0B%

   Rear Side Airbag Crash Sensor (on driver's side):
   Serial number: 3515RRB405L0MFP63GQ7

   Passenger side rear thorax airbag crash sensor:
   Serial number: 3525RRB405H0MFP6C8N2

   Crash sensor for front airbag: driver side:
   Serial number: 3555NRB405B0JL5I48RT

   Crash sensor for front airbag: front passenger side:
   Serial number: 3565NRB405D0JL5I91AD

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527)       Labels:. 4H0-953-568.clb
   Part No SW: 4H0 953 568 F    HW: 7P6 953 507 L
   Component: Lenks.Modul   H03 0005 
   Revision: --------    Serial number: 90815KIT0003K
   Coding: 000015
   Shop #: WSC 31414 790 00001
   VCID: 36362F363847B52AC5F-8062

   Subsystem 1 - Part No SW: 7P6 959 542     HW: 7P6 959 542
   Component: E221__MFL-TAS  H03 0027
   Serial number: 0111221             

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 7P6-920-xxx-17.clb-SRI1
   Part No SW: 7P6 920 980 N    HW: 7P6 920 980 N
   Component: Kombi         H13 0239 
   Revision: 11240062    Serial number: 658280911592007
   Coding: 8B7733022B00CF05020004
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_KombiUDSRBVW526 001013
   ROD: EV_KombiUDSRBVW526.rod
   VCID: 47C852F24F2D3CA2AE9-8012

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:* None
   Part No SW: 7P6 907 530 C    HW: 7P6 907 530 A
   Component: GW-CAN-L-MOST H08 5202 
   Revision: --------    Serial number: 00000000257029
   Coding: 0001037500
   Shop #: WSC 31414 790 00001
   GVL: FB4F40451D7B000000
   ASAM Dataset: EV_GatewVW526UDS 001006
   ROD: EV_GatewUDS_VW52.rod
   VCID: 382A210E32D3435AD73-806C

   Battery Monitoring Control Module:
   Subsystem 1 - Part No SW: 7P0 915 181 A    HW: 7P0 915 181
   Component: Batt_Sensor  H07 0140
   Serial number: 40296422534191204774

No fault code found.

-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136)       Labels: None
   Part No SW: 4H0 959 760 D    HW: 4H0 959 760 D
   Component: MEM-FS        H08 0153 
   Revision: AA000000    Serial number: 00000013819972
   Coding: 0058130000004001000001010101202020202121202020
   Shop #: WSC 31414 790 00001
   VCID: 3432153E2E3BA73AFBB-8060

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:. 4H0-959-793.clb
   Part No SW: 4H0 959 793 N    HW: 4H0 959 793 F
   Component: TSG FA        H07 0166 
   Revision: --------    Serial number: 0000120203920
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 44D245FE7E9B17BA4BB-8010

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv. (J393)       Labels:. 4H0-907-064-46.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H31 0330 
   Revision: 00002001    Serial number: 0158646713   
   Coding: 0186123A28B9509480A00620210000000000000000000000000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B0D6226BB5E002221-8026

   Subsystem 1 - Part No SW: 7P6 959 719     HW: 7P6 959 719
   Component: GTO BT  H19 0058
   Serial number: 216111595           

   Subsystem 2 - Part No: 1K0 951 605 C
   Component: LIN BACKUP HO  H05 1501

   Subsystem 3 - Part No SW: 7P0 959 591     HW: 7P0 959 591
   Component: J245 PS30.050  H07 0006
   Serial number:     WOO1355042.     
   Coding: 191100

   Subsystem 4 - Part No SW: 7P0 959 591 A    HW: 4H0 959 591
   Component: J394 PS30.050  H07 0006
   Serial number:     WOO1360418/     
   Coding: 191100

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:. 4H0-959-792.clb
   Part No SW: 4H0 959 792 F    HW: 4H0 959 792 F
   Component: TSG BF        H07 0166 
   Revision: --------    Serial number: 0000120323875
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 3B203E02036568423A1-806E

No fault code found.

-------------------------------------------------------------------------------
Address 53: Parking Brake (J540-)       Labels:| 7P0-907-801.clb
   Part No SW: 7P0 907 801 F    HW: 7P0 907 801 F
   Component: EPB           H51 1201 
   Revision: 00000000    Serial number: A1191100112    Dataset Number:             A001
   Coding: 01040200
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_ParkbA7 000006
   ROD: EV_ParkbA7.rod
   VCID: 36362F3638C7B52AC5F-8062

   Slave 3:

No fault code found.

-------------------------------------------------------------------------------
Address 55: Headlight Range (J745)       Labels:. 7P6-907-357.clb
   Part No SW: 7P6 907 357     HW: 7L6 907 357 C
   Component: AFS-ECU       H04 0110 
   Revision: --------    Serial number: -------------- Dataset Number: 7P0036v____ 0009
   Coding: 010A00010F000400
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeadlRegulVWAFS 005006
   ROD: EV_HeadlRegulVWAFS_VW52.rod
   VCID: 7CA2FD1E466BAF7A73B-8028

   Left_headlamp_power_output_stage:
   Subsystem 1 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo links  H01 0002
   Coding: 130000

   Right_headlamp_power_output_stage:
   Subsystem 2 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo rechts  H01 0002
   Coding: 130000

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (R)       Labels:. 4F0-035-0xx-56.clb
   Part No SW: 4G0 035 082 B    HW: 4G0 035 082
   Component: Radio U SIRIU H53 0076 
   Revision: AB001007    Serial number: 156I%0B7554931
   Coding: 020007020100000001
   Shop #: WSC 31414 790 00001
   VCID: 1F18EA92B7BD1462369-804A

No fault code found.

-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794)       Labels:. 4E0-035-6xx-5F.clb
   Part No SW: 7P6 035 664 B    HW: 7P6 035 664
   Component: H-BN-NA       H44 0319 
   Revision: --------    Serial number: 445I20B7520788
   Coding: 010200050040E1ED41022B0E00000003F0000101
   Shop #: WSC 31414 790 00001
   VCID: 372822323F4D4C22DE9-8062

   Subsystem 1 - Part No: 8R0 060 884 AC
   Component: NAR 2011  0503

   Subsystem 2 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9L79004CE     

   Subsystem 3 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9L79004CE     

   Subsystem 4 - Part No: 8R0 060 961
   Component: CD-Database  1886

No fault code found.

-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HL        H09 0167 
   Revision: --------    Serial number: 0000120197821
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2E3B060C5F514A217-806E

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502)       Labels: 3Y0-907-273.clb
   Part No SW: 7P6 907 273 F    HW: 7P6 907 273 F
   Component: RDKBERU25     H09 0008 
   Serial number: 10000000045970 Dataset Number: 7P6096v____ 0017
   ASAM Dataset: EV_RDKBERU25 003006
   ROD: EV_RDKBERU25_VW52.rod
   VCID: 3FD84A1217FD7462169-806A

No fault code found.

-------------------------------------------------------------------------------
Address 69: Trailer (J345)       Labels: Redir Fail!
   Part No SW: 7P0 907 383 F    HW: 7P0 907 383 B
   Component: Anhaenger     H09 0110 
   Revision: 5A001001    Serial number: 00000157631323
   Coding: 020D000000000000
   Shop #: WSC 31414 790 00001
   VCID: 3B203E02036568423A1-806E

No fault code found.

-------------------------------------------------------------------------------
Address 6D: Trunk Elect. (----)       Labels:| 7N0-959-107.clb
   Part No SW: 7P6 959 107 A    HW: 7P6 959 107
   Component: HDSG-Modul    H10 0620 
   Revision: 22010001    Serial number: 258100389 Dataset Number: 7P6959107A  D043
   Coding: 0533314003
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeckkTouar 202137
   ROD: EV_HeckkTouar.rod
   VCID: 3D24301A1DF16672045-8068

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HR        H09 0167 
   Revision: --------    Serial number: 0000120196514
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2E3B060C5F514A217-806E

No fault code found.

End----(Elapsed Time: 02:08, VBatt start/end: 11.8V/11.9V. VIgn 11.9V)-----
 
#58 ·
The point I'm trying to convey to you and all others going at troubleshooting and attempting to fix their stuff is that you never erase codes unless you've already understood what set them off. All codes and FF data contain clues and useful information which will help you go down the right path.

Anywho, let's get to it now.

See how your current code is nothing like all the prior codes?

Which NOx sensor did you say you took out and cleaned?
 
41 - 60 of 81 Posts
About this Discussion
80 Replies
7 Participants
Last post:
SaVAGeSoot
Club Touareg Forum
posts
784K
members
105K
Since
2003
Club Touareg Forum is a forum community dedicated to Volkswagen Touareg owners and enthusiasts. Come join the discussion about VW Touareg Sport Utility Vehicles and more!
Full Forum Listing
Explore Our Forums
General Maintenance & Repair Australia & New Zealand Brakes, Steering, Suspension, Wheels and Tires Mobile Electronics and In Car Entertainment General Touareg Discussions