Club Touareg Forum banner
Cancel
Create thread New Garage Forums

Multiple sensor failures

1 reading
Jump to Latest
1 - 20 of 21 Posts
K

ksykes

· Registered
Joined
·
15 Posts
Discussion starter · #1 ·
hello, i was driving home last month when i got a DPF warning light. this got me going down a rabbit hole of fixing parts. I took the DPF and pre-catalytic converter to a local shop that repairs them (cooks them at 1100 degrees for 11 hours), while i was at it i decided to tackle my leaky turbo. Once i got that pulled i decided to pull the motor and fix the timing cover leak. It's all back together now but i'm receiving the same engine troubles as before (DPF warning). i'm getting the 4 errors below. Is it likely that multiple sensors went out at the same time or do i have some other problem? Is my DPF still a problem or am i just having issues due to bad sensors?

4 Faults Found:
5188 - Particle Filter
P2463 00 [167] - Excessive Soot Accumulation
MIL ON - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 277642 km
Date: 2023.09.29
Time: 03:40:52

Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 63 C
Intake air temperature: 31 C
Ambient air pressure: 980 mbar
Voltage terminal 30: 11.740 V
Unlearning counter according OBD: 40
P Flt Ld fac Ash Cor: 0.6200
Particul.filter diff.pressure: 2 hPa
Exh t Adap T Oxi Cat Ds: 44.0 C
Exh t Adap TP Flt Ds: 222.0 C
Exhaust gas jet volume in particle filter: 0.0 m /h

5189 - Particulate Trap Bank 1
P2002 00 [039] - Efficiency Below Threshold
Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 277642 km
Date: 2023.09.29
Time: 03:40:52

Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 63 C
Intake air temperature: 31 C
Ambient air pressure: 980 mbar
Voltage terminal 30: 11.740 V
Unlearning counter according OBD: 40
Ambient temperature: 20.5 C
DPF: offset for differential pressure: 1 hPa
Particle filter: soot mass measured: 24.05 g
Particle filter: soot mass calculated: 27.93 g
Particle filter: kilometers since last regeneration: 238894 m
Particle filter field regeneration: cancel conditions-Bits 0-7: 0
Particle filter field regeneration: cancel conditions-Bits 0-7: 1

5448 - Exhaust Gas Temp Sensor; Bank 1 Sensor 2
P2031 00 [039] - Electrical Malfunction
Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 277642 km
Date: 2023.09.29
Time: 03:40:49

Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 63 C
Intake air temperature: 31 C
Ambient air pressure: 980 mbar
Voltage terminal 30: 11.740 V
Unlearning counter according OBD: 40
Exhaust gas temperature sensor 1: 222.8 C
Exhaust gas temperature sensor 2: 1000.0 C
Exhaust gas temperature sensor 3: 44.0 C
Exhaust gas temperature sensor 4: 1000.0 C
Shut-off timer: last engine shut-off time: 1698 s

5258 - Exhaust Gas Temperature Sensor 4 Bank 1
P246E 00 [039] - Electrical Malfunction
Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 277642 km
Date: 2023.09.29
Time: 03:40:49

Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 63 C
Intake air temperature: 31 C
Ambient air pressure: 980 mbar
Voltage terminal 30: 11.740 V
Unlearning counter according OBD: 40
Exhaust gas temperature sensor 1: 222.8 C
Exhaust gas temperature sensor 2: 1000.0 C
Exhaust gas temperature sensor 3: 44.0 C
Exhaust gas temperature sensor 4: 1000.0 C
Shut-off timer: last engine shut-off time: 1698 s

Readiness: 0 0 0 1 1
 
#4 ·
ksykes said:
hello, i was driving home last month when i got a DPF warning light. this got me going down a rabbit hole of fixing parts. I took the DPF and pre-catalytic converter to a local shop that repairs them (cooks them at 1100 degrees for 11 hours), while i was at it i decided to tackle my leaky turbo. Once i got that pulled i decided to pull the motor and fix the timing cover leak. It's all back together now but i'm receiving the same engine troubles as before (DPF warning). i'm getting the 4 errors below. Is it likely that multiple sensors went out at the same time or do i have some other problem? Is my DPF still a problem or am i just having issues due to bad sensors?

4 Faults Found:
5188 - Particle Filter
P2463 00 [167] - Excessive Soot Accumulation
MIL ON - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 277642 km
Date: 2023.09.29
Time: 03:40:52

Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 63 C
Intake air temperature: 31 C
Ambient air pressure: 980 mbar
Voltage terminal 30: 11.740 V
Unlearning counter according OBD: 40
P Flt Ld fac Ash Cor: 0.6200
Particul.filter diff.pressure: 2 hPa
Exh t Adap T Oxi Cat Ds: 44.0 C
Exh t Adap TP Flt Ds: 222.0 C
Exhaust gas jet volume in particle filter: 0.0 m /h

5189 - Particulate Trap Bank 1
P2002 00 [039] - Efficiency Below Threshold
Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 277642 km
Date: 2023.09.29
Time: 03:40:52

Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 63 C
Intake air temperature: 31 C
Ambient air pressure: 980 mbar
Voltage terminal 30: 11.740 V
Unlearning counter according OBD: 40
Ambient temperature: 20.5 C
DPF: offset for differential pressure: 1 hPa
Particle filter: soot mass measured: 24.05 g
Particle filter: soot mass calculated: 27.93 g
Particle filter: kilometers since last regeneration: 238894 m
Particle filter field regeneration: cancel conditions-Bits 0-7: 0
Particle filter field regeneration: cancel conditions-Bits 0-7: 1

5448 - Exhaust Gas Temp Sensor; Bank 1 Sensor 2
P2031 00 [039] - Electrical Malfunction
Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 277642 km
Date: 2023.09.29
Time: 03:40:49

Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 63 C
Intake air temperature: 31 C
Ambient air pressure: 980 mbar
Voltage terminal 30: 11.740 V
Unlearning counter according OBD: 40
Exhaust gas temperature sensor 1: 222.8 C
Exhaust gas temperature sensor 2: 1000.0 C
Exhaust gas temperature sensor 3: 44.0 C
Exhaust gas temperature sensor 4: 1000.0 C
Shut-off timer: last engine shut-off time: 1698 s

5258 - Exhaust Gas Temperature Sensor 4 Bank 1
P246E 00 [039] - Electrical Malfunction
Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 277642 km
Date: 2023.09.29
Time: 03:40:49

Engine RPM: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 63 C
Intake air temperature: 31 C
Ambient air pressure: 980 mbar
Voltage terminal 30: 11.740 V
Unlearning counter according OBD: 40
Exhaust gas temperature sensor 1: 222.8 C
Exhaust gas temperature sensor 2: 1000.0 C
Exhaust gas temperature sensor 3: 44.0 C
Exhaust gas temperature sensor 4: 1000.0 C
Shut-off timer: last engine shut-off time: 1698 s

Readiness: 0 0 0 1 1
Click to expand...
I've noticed in other threads where owners have had multiple sensor/module faults they realized they had a failing battery.
Not saying this is your cause, just curious as to how old your battery is?
 
Save
Reply Quote Like Like
#5 ·
If you post up your full auto-scan, you can "Code Wrap" it by following the thread below.

Code Wrap an auto-scan
 
Save
Reply Quote Like Like
#7 ·
Those are dead.... that's the max those sensors can see...
Also, considering that the FF data shows issues already as far as 3 weeks ago, depending on how much he's driven under these no regen conditions, running normally again might take way more than just replacing the two dead EGT probes.....
 
#8 ·
SaVAGeSoot said:
Those are dead.... that's the max those sensors can see...
Also, considering that the FF data shows issues already as far as 3 weeks ago, depending on how much he's driven under these no regen conditions, running normally again might take way more than just replacing the two dead EGT probes.....
Click to expand...
Yeah DPF is probably full again which means it has to come off again without a regen burning the vehicle down. Glad it's not my money
 
Discussion starter · #10 ·
Thank you for the replies and sorry for the delay. Vehicle hasn't been driven since the work had been done so DPF shouldnt have anything in it. I'll try and post the full scan later. With that said since I've completed the work the battery will not hold a charge. I'm guessing it's no good. I'll change that out tomorrow and let you know if anything else changed.
 
Discussion starter · #11 ·
let me know if i leaded the info incorrectly. Also any idea how i determine which sensor (and part number) exhaust 4 bank 1 is?

Code: 
Monday,23,October,2023,10:36:58:58995
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 11 x64
VCDS Version: 23.3.1.0 (x64)  HEX-V2 CB: 0.4631.4
Data version: 20230421 DS346.2
www.Ross-Tech.com


VIN: WVGEP9BP3DD000603   License Plate:


Chassis Type: BP-VW52 (7P6)
Scan: 01 02 03 05 08 09 15 16 17 19 36 42 46 52 53 55 56 5F 62 65
          69 6C 6D 72

VIN: WVGEP9BP3DD000603   Mileage: 277642km-172518miles

01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: Malfunction 0010
69-Trailer -- Status: OK 0000
6C-Back-up Cam. -- Status: OK 0000
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CNRB)       Labels:. 059-907-401-V2.clb
   Part No SW: 7P0 907 401 K    HW: 7P0 907 401 K
   Component: 3.0TDI FSA    H17 0011 
   Revision: 56H17---    CVN: E7FCBDE45C3E0D045C3E0D040E1FC39E
   Coding: 292A4012233600050000
   Shop #: WSC 23324 444 00000
   ASAM Dataset: EV_ECM30TDI0117P0907401K 001012
   ROD: EV_ECM30TDI0117P0907401K.rod
   VCID: 372B24EF8FC3E382FE1-8062
   VINID: 9E65D58094A00D45000001800C60B5CFBD

3 Faults Found:
5188 - Particle Filter
          P2463 00 [175] - Excessive Soot Accumulation
          MIL ON - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 277642 km
                    Date: 2023.10.05
                    Time: 00:14:12

                    Engine RPM: 0.00 /min
                    Normed load value: 0.0 %
                    Vehicle speed: 0 km/h
                    Coolant temperature: 13 °C
                    Intake air temperature: 15 °C
                    Ambient air pressure: 970 mbar
                    Voltage terminal 30: 12.100 V
                    Unlearning counter according OBD: 40
                    P Flt Ld fac Ash Cor: 0.6200
                    Particul.filter diff.pressure: 2 hPa
                    Exh t Adap T Oxi Cat Ds: 19.7 °C
                    Exh t Adap TP Flt Ds: 222.0 °C
                    Exhaust gas jet volume in particle filter: 0.0 m³/h

5189 - Particulate Trap Bank 1
          P2002 00 [047] - Efficiency Below Threshold
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 277642 km
                    Date: 2023.10.05
                    Time: 00:14:12

                    Engine RPM: 0.00 /min
                    Normed load value: 0.0 %
                    Vehicle speed: 0 km/h
                    Coolant temperature: 13 °C
                    Intake air temperature: 15 °C
                    Ambient air pressure: 970 mbar
                    Voltage terminal 30: 12.100 V
                    Unlearning counter according OBD: 40
                    Ambient temperature: 13.0 °C
                    DPF: offset for differential pressure: 1 hPa
                    Particle filter: soot mass measured: 24.05 g
                    Particle filter: soot mass calculated: 28.04 g
                    Particle filter: kilometers since last regeneration: 238951 m
                    Particle filter field regeneration: cancel conditions-Bits 0-7: 0
                    Particle filter field regeneration: cancel conditions-Bits 0-7: 1

5258 - Exhaust Gas Temperature Sensor 4 Bank 1
          P246E 00 [175] - Electrical Malfunction
          MIL ON - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 277642 km
                    Date: 2023.10.05
                    Time: 00:14:09

                    Engine RPM: 0.00 /min
                    Normed load value: 0.0 %
                    Vehicle speed: 0 km/h
                    Coolant temperature: 13 °C
                    Intake air temperature: 15 °C
                    Ambient air pressure: 970 mbar
                    Voltage terminal 30: 12.120 V
                    Unlearning counter according OBD: 40
                    Exhaust gas temperature sensor 1: 28.7 °C
                    Exhaust gas temperature sensor 2: 27.8 °C
                    Exhaust gas temperature sensor 3: 19.7 °C
                    Exhaust gas temperature sensor 4: 1000.0 °C
                    Shut-off timer: last engine shut-off time: 398 s

Readiness: 1 2 0 1 1

-------------------------------------------------------------------------------
Address 02: Auto Trans (J217)       Labels:| 0C8-927-7XX-V1.clb
   Part No SW: 0C8 927 750 AK    HW: 0C8 927 750 A
   Component: AL1000 AISIN  001 3398 
   Serial number:                CVN: A4540B9E
   Coding: 001368
   Shop #: WSC 63090 001 1048576
   ASAM Dataset: EV_TCMAL991031 002115
   ROD: EV_TCMAL991031_002_VW52.rod
   VCID: 75B7EEE7D54F51922CD-8020

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:* 7P0-907-379.clb
   Part No SW: 7P0 907 379 M    HW: 7P0 907 379 A
   Component: MK25A         H36 0436 
   Revision: --------    Serial number: 414020010EC815 Dataset Number: 7P0012v____ 7P16
   Coding: 5B7613C349242553DAFAC89392D5A4407300
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_MK25AXT 008001
   ROD: EV_ESPMK25A00800.rod
   VCID: 47CB542FFF2393028E1-8012

No fault code found.

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393)       Labels:. 8K0-907-064-05.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H32 0333 
   Revision: 00002001   
   Coding: 09860010000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B3D0FFDBBB4FA2029-8026

   Subsystem 1 - Part No SW: 7P6 959 754 M    HW: 7P6 959 754 M
   Component: FBSTOUAREGIDG  H04 0051
   Serial number: 0512000023605013   

   Subsystem 2 - Part No SW: 4H0 905 852 B    HW: 4H0 905 852 B
   Component: J764 ELV MLB  H40 0046
   Serial number: 2312000103820012   

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels:| 7P6-907-040.clb
   Part No SW: 7P6 907 040 BK    HW: 7P6 907 040 BK
   Component: Klima 2 Zonen H20 1305 
   Coding: B606200A80
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirCondiFront 004001
   ROD: EV_AirCondiFront_VW52.rod
   VCID: 7EA5F1CBE07912CA7D7-802A

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 4H0-907-063-V1.clb
   Part No SW: 4H0 907 063 BL    HW: 4H0 907 063 D
   Component: BCM1 2.0      H12 0111 
   Revision: 15012002    Serial number: 00000001337544
   Coding: 26001012973C5D010020180300005D0C431C660882010261000000020000
   Shop #: WSC 31414 790 00001
   VCID: 73B3D0FFDBBB4FA2029-8026

   Subsystem 1 - Part No SW: 7P0 955 119     HW: 7P0 955 119   Labels: 1KX-955-119.CLB
   Component: WWS    120503  31  0020
   Serial number: 90243400120521170321
   Coding: 004DBD

   Subsystem 2 - Part No SW: 7P0 955 559 D    HW: 7P0 955 559 D  Labels: 8K0-955-559.CLB
   Component: RLFS  H09 0011
   Serial number: 10388717           
   Coding: 025223

   Subsystem 3 - Part No SW: 7P6 941 431 E    HW: 7P6 941 431 E
   Component: E1 - LDS  H04 0031
   Serial number: 00000000002205121003

   Subsystem 4 - Part No SW: 4H0 907 410 A    HW: 4H0 907 410 A
   Component: USHL4.2  H30 0020
   Serial number: 0000001805569R12DN07

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels:| 7P0-959-655.clb
   Part No SW: 7P0 959 655 C    HW: 7P0 959 655 C
   Component: VW10Airbag025 H05 0025 
   Revision: --------    Serial number: 003L0003E8FL Dataset Number: 7P6003v____ 0983
   Coding: 000000000000000000000000000000003235
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirbaVW10BPAVW526 001001
   ROD: EV_AirbaVW10BPAVW526_001.rod
   VCID: 41DF4A37D107AD32405-8014

   Seat occupied recognition:
   Subsystem 1 - Part No SW: 7P6 959 339     HW: 7P6 959 339
   Component: BF-Gewichtss.  003 0005
   Serial number: 5850000R12301089MT

   Crash sensor for side airbag: driver side:
   Serial number: 3575LRB405D1D5MSBPPG

   Front Passenger's Side Airbag Crash Sensor:
   Serial number: 3585LRB405F1D5MS506C

   Rear Side Airbag Crash Sensor (on driver's side):
   Serial number: 3515RRB405718B7489FT

   Passenger side rear thorax airbag crash sensor:
   Serial number: 3525RRB404P18B74F9OK

   Crash sensor for front airbag: driver side:
   Serial number: 3555NRB400M4UE2051G5

   Crash sensor for front airbag: front passenger side:
   Serial number: 3565NRB400M4UE20D0RO

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527)       Labels:. 4H0-953-568.clb
   Part No SW: 4H0 953 568 F    HW: 7P6 953 507 L
   Component: Lenks.Modul   H03 0005 
   Revision: --------    Serial number: 90815LEP0004J
   Coding: 000015
   Shop #: WSC 31414 790 00001
   VCID: 363529EB88491A8AE57-8062

   Subsystem 1 - Part No SW: 7P6 959 542     HW: 7P6 959 542
   Component: E221__MFL-TAS  H03 0027
   Serial number: 0183151             

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 7P6-920-xxx-17.clb-SRI1
   Part No SW: 7P6 920 981 F    HW: 7P6 920 981 F
   Component: Kombi         H14 0318 
   Revision: 14240078    Serial number: 658250512592025
   Coding: 8B7733022B00CF05020004
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_KombiUDSRBVW526 001017
   ROD: EV_KombiUDSRBVW526.rod
   VCID: 40D94F33DA0DA43A4FB-8014

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:* None
   Part No SW: 7P6 907 530 F    HW: 7P6 907 530 F
   Component: GW-CAN-L-MOST H10 6028 
   Revision: --------    Serial number: 00000000549394 Dataset Number: 7P6067v____ 0022
   Coding: 0001037500
   Shop #: WSC 31414 790 00001
   GVL: FB0F40451D7F000000
   ASAM Dataset: EV_GatewVW526UDS 001007
   ROD: EV_GatewUDS_VW52.rod
   VCID: 3B2338DFB3EBC7E21A9-806E

   Battery Monitoring Control Module:
   Subsystem 1 - Part No SW: 7P0 915 181 A    HW: 7P0 915 181
   Component: Batt_Sensor  H07 0140
   Serial number: 00000000005650422198

No fault code found.

-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136)       Labels: None
   Part No SW: 4H0 959 760 D    HW: 4H0 959 760 D
   Component: MEM-FS        H08 0153 
   Revision: AA000000    Serial number: 00000030085187
   Coding: 0058130000004001000001010101202020202121202020
   Shop #: WSC 31414 790 00001
   VCID: 343113E39E35089ADB3-8060

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:. 4H0-959-793.clb
   Part No SW: 4H0 959 793 N    HW: 4H0 959 793 F
   Component: TSG FA        H07 0166 
   Revision: --------    Serial number: 0000127939530
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 44D14323CE95B81A6B3-8010

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv. (J393)       Labels:. 4H0-907-064-46.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H32 0333 
   Revision: 00002001    Serial number: 0177139760   
   Coding: 0186123A28B9509480A00620210000000000000000000000000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B3D0FFDBBB4FA2029-8026

   Subsystem 1 - Part No SW: 7P6 959 719     HW: 7P6 959 719
   Component: GTO BT  H19 0059
   Serial number: 1151212846         

   Subsystem 2 - Part No: 1K0 951 605 C
   Component: LIN BACKUP HO  H05 1501

   Subsystem 3 - Part No SW: 7P0 959 591 B    HW: 7P0 959 591 B
   Component: J245 PS30.055  H01 0008
   Serial number:     WOO1611144Z     
   Coding: 191100

   Subsystem 4 - Part No SW: 7P0 959 591 C    HW: 7P0 959 591 C
   Component: J394 PS30.055  H01 0008
   Serial number:     WOO1645013.     
   Coding: 191100

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:. 4H0-959-792.clb
   Part No SW: 4H0 959 792 F    HW: 4H0 959 792 F
   Component: TSG BF        H07 0166 
   Revision: --------    Serial number: 0000127799673
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 3B2338DFB36BC7E21A9-806E

No fault code found.

-------------------------------------------------------------------------------
Address 53: Parking Brake (J540-)       Labels:| 7P0-907-801.clb
   Part No SW: 7P0 907 801 F    HW: 7P0 907 801 F
   Component: EPB           H51 1201 
   Revision: 00000000    Serial number: C1252200183    Dataset Number:             A001
   Coding: 01040200
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_ParkbA7 000006
   ROD: EV_ParkbA7.rod
   VCID: 363529EB88C91A8AE57-8062

   Slave 3:

No fault code found.

-------------------------------------------------------------------------------
Address 55: Headlight Range (J745)       Labels:. 7P6-907-357.clb
   Part No SW: 7P6 907 357     HW: 7L6 907 357 C
   Component: AFS-ECU       H04 0110 
   Revision: --------    Serial number: -------------- Dataset Number: 7P0036v____ 0009
   Coding: 010A00010F000400
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeadlRegulVWAFS 005006
   ROD: EV_HeadlRegulVWAFS_VW52.rod
   VCID: 7CA1FBC3F66500DA533-8028

   Left_headlamp_power_output_stage:
   Subsystem 1 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo links  H01 0003
   Coding: 130000

   Right_headlamp_power_output_stage:
   Subsystem 2 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo rechts  H01 0003
   Coding: 130000

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (R)       Labels:. 4F0-035-0xx-56.clb
   Part No SW: 4G0 035 082 D    HW: 4G0 035 082
   Component: Radio U SIRIU H60 0112 
   Revision: AB001007    Serial number: 156E30C7598444
   Coding: 020007020000000001
   Shop #: WSC 31414 790 00001
   VCID: 211FEAB731C78D32205-8074

No fault code found.

-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794)       Labels:. 4E0-035-6xx-5F.clb
   Part No SW: 7P6 035 664 C    HW: 7P6 035 664
   Component: H-BN-NA       H45 0544 
   Revision: --------    Serial number: 445E20C7535398
   Coding: 010200050040E1EE41022B0C00000003F0000100
   Shop #: WSC 31414 790 00001
   VCID: 382927D3825DECFAF7B-806C

   Subsystem 1 - Part No: 8R0 060 884 AM
   Component: NAR 2012  0605

   Subsystem 2 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9M7900ALW     

   Subsystem 3 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9M7900ALW     

   Subsystem 4 - Part No: 8R0 060 961
   Component: CD-Database  1886

No fault code found.

-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HL        H09 0167 
   Revision: --------    Serial number: 0000127808286
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2D3DDBBC51FEEA01F-806E

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502)       Labels: 3Y0-907-273.clb
   Part No SW: 7P6 907 273 F    HW: 7P6 907 273 F
   Component: RDKBERU25     H09 0008 
   Serial number: 10000000078587 Dataset Number: 7P6096v____ 0018
   ASAM Dataset: EV_RDKBERU25 003006
   ROD: EV_RDKBERU25_VW52.rod
   VCID: 3FDB4CCFA7F3DBC2361-806A

4 Faults Found:
8397058 - Front Left TPMS Sensor
          C1050 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18 °C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV

8397314 - Front Right TPMS Sensor
          C1051 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18 °C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV

8397570 - Rear Left TPMS Sensor
          C1052 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18 °C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV

8397826 - Rear Right TPMS Sensor
          C1053 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18 °C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV


-------------------------------------------------------------------------------
Address 69: Trailer (J345)       Labels: Redir Fail!
   Part No SW: 7P0 907 383 F    HW: 7P0 907 383 B
   Component: Anhaenger     H09 0110 
   Revision: 5A001001    Serial number: 00000176601350
   Coding: 020D000000000000
   Shop #: WSC 31414 790 00001
   VCID: 3B2338DFB36BC7E21A9-806E

No fault code found.

-------------------------------------------------------------------------------
Address 6C: Back-up Cam.        Labels: 4L0-910-441.clb
   Part No SW: 7P6 907 441 A    HW: 4H0 907 441
   Component: SG Rueckfahrkamera  0020 
   Revision: 00H06000    Serial number: 525 PA8J242660
   Coding: 0110001
   Shop #: WSC 31414 790 00001
   VCID: 372B24EF8343E382FE1-8062

No fault code found.

-------------------------------------------------------------------------------
Address 6D: Trunk Elect. (----)       Labels:| 7N0-959-107.clb
   Part No SW: 7P6 959 107 A    HW: 7P6 959 107
   Component: HDSG-Modul    H10 0620 
   Revision: 22010001    Serial number: 129200525 Dataset Number: 7P6959107A  D043
   Coding: 0533314003
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeckkTouar 202137
   ROD: EV_HeckkTouar.rod
   VCID: 3D2736C7ADFFC9D224D-8068

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HR        H09 0167 
   Revision: --------    Serial number: 0000127811258
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2D3DDBBC51FEEA01F-806E

No fault code found.

End----------(Elapsed Time: 02:02, VBatt start/end: 12.0V/12.2V)-----------
 
#12 ·
ksykes said:
Also any idea how i determine which sensor (and part number) exhaust 4 bank 1 is?
Click to expand...
You would use the shop manual.
It's the last EGT probe, after the DPF.
You need to replace that so that the active regens can once again take place.
Right now, you've reached the point where the ecu wants an active regen, but because of your failed sensor, it will not do it...
Looks like your last successful regen was about 148 miles ago.
 
Discussion starter · #13 ·
Sensor was replaced and sensor malfunction has cleared. So at this point I've replaced two failed sensors and had the DPF cleaned. The ECU will not allow me run a dpf regen using VCDS and i'm not sure how to clear it. Any ideas? The limp mode will prevent driving it to clear it so it needs to cleared stationary. waiting for approval on the ross-tech forum to post as i can't find a specific answer for the 3.0 gen 3. Here is the most recent code pull:

Code: 
Thursday,26,October,2023,18:00:27:58995
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 11 x64
VCDS Version: 23.3.1.0 (x64)  HEX-V2 CB: 0.4631.4
Data version: 20230421 DS346.2
www.Ross-Tech.com


VIN: WVGEP9BP3DD000603   License Plate: B
Mileage: 277642km-172518mi   Repair Order:



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: BP-VW52 (7P6)
Scan: 01 02 03 05 08 09 15 16 17 19 36 42 46 52 53 55 56 5F 62 65
          69 6C 6D 72

VIN: WVGEP9BP3DD000603   Mileage: 277642km-172518miles

01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: Malfunction 0010
69-Trailer -- Status: OK 0000
6C-Back-up Cam. -- Status: OK 0000
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CNRB)       Labels:. 059-907-401-V2.clb
   Part No SW: 7P0 907 401 K    HW: 7P0 907 401 K
   Component: 3.0TDI FSA    H17 0011 
   Revision: 56H17---    CVN: E7FCBDE45C3E0D045C3E0D040E1FC39E
   Coding: 292A4012233600050000
   Shop #: WSC 23324 444 00000
   ASAM Dataset: EV_ECM30TDI0117P0907401K 001012
   ROD: EV_ECM30TDI0117P0907401K.rod
   VCID: 372B24EF8FC3E382FE1-8062
   VINID: 9E65D58094A00D45000001800C60B5CFBD

2 Faults Found:
5188 - Particle Filter
          P2463 00 [167] - Excessive Soot Accumulation
          MIL ON - Not Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 277642 km
                    Date: 2023.10.08
                    Time: 07:47:22

                    Engine RPM: 808.00 /min
                    Normed load value: 16.9 %
                    Vehicle speed: 0 km/h
                    Coolant temperature: 11  C
                    Intake air temperature: 8  C
                    Ambient air pressure: 990 mbar
                    Voltage terminal 30: 13.940 V
                    Unlearning counter according OBD: 40
                    P Flt Ld fac Ash Cor: 0.6200
                    Particul.filter diff.pressure: 7 hPa
                    Exh t Adap T Oxi Cat Ds: 36.9  C
                    Exh t Adap TP Flt Ds: 28.3  C
                    Exhaust gas jet volume in particle filter: 72.6 m /h
A
5189 - Particulate Trap Bank 1
          P2002 00 [039] - Efficiency Below Threshold
          Not Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 277642 km
                    Date: 2023.10.08
                    Time: 07:47:22

                    Engine RPM: 808.00 /min
                    Normed load value: 16.9 %
                    Vehicle speed: 0 km/h
                    Coolant temperature: 11  C
                    Intake air temperature: 8  C
                    Ambient air pressure: 990 mbar
                    Voltage terminal 30: 13.940 V
                    Unlearning counter according OBD: 40
                    Ambient temperature: 8.0  C
                    DPF: offset for differential pressure: 1 hPa
                    Particle filter: soot mass measured: 24.05 g
                    Particle filter: soot mass calculated: 28.10 g
                    Particle filter: kilometers since last regeneration: 238951 m
                    Particle filter field regeneration: cancel conditions-Bits 0-7: 0
                    Particle filter field regeneration: cancel conditions-Bits 0-7: 0

Readiness: 0 0 0 1 1

-------------------------------------------------------------------------------
Address 02: Auto Trans (J217)       Labels:| 0C8-927-7XX-V1.clb
   Part No SW: 0C8 927 750 AK    HW: 0C8 927 750 A
   Component: AL1000 AISIN  001 3398 
   Serial number:                CVN: A4540B9E
   Coding: 001368
   Shop #: WSC 63090 001 1048576
   ASAM Dataset: EV_TCMAL991031 002115
   ROD: EV_TCMAL991031_002_VW52.rod
   VCID: 75B7EEE7D54F51922CD-8020

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:* 7P0-907-379.clb
   Part No SW: 7P0 907 379 M    HW: 7P0 907 379 A
   Component: MK25A         H36 0436 
   Revision: --------    Serial number: 414020010EC815 Dataset Number: 7P0012v____ 7P16
   Coding: 5B7613C349242553DAFAC89392D5A4407300
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_MK25AXT 008001
   ROD: EV_ESPMK25A00800.rod
   VCID: 47CB542FFF2393028E1-8012

No fault code found.

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393)       Labels:. 8K0-907-064-05.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H32 0333 
   Revision: 00002001   
   Coding: 09860010000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B3D0FFDBBB4FA2029-8026

   Subsystem 1 - Part No SW: 7P6 959 754 M    HW: 7P6 959 754 M
   Component: FBSTOUAREGIDG  H04 0051
   Serial number: 0512000023605013   

   Subsystem 2 - Part No SW: 4H0 905 852 B    HW: 4H0 905 852 B
   Component: J764 ELV MLB  H40 0046
   Serial number: 2312000103820012   

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels:| 7P6-907-040.clb
   Part No SW: 7P6 907 040 BK    HW: 7P6 907 040 BK
   Component: Klima 2 Zonen H20 1305 
   Coding: B606200A80
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirCondiFront 004001
   ROD: EV_AirCondiFront_VW52.rod
   VCID: 7EA5F1CBE07912CA7D7-802A

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 4H0-907-063-V1.clb
   Part No SW: 4H0 907 063 BL    HW: 4H0 907 063 D
   Component: BCM1 2.0      H12 0111 
   Revision: 15012002    Serial number: 00000001337544
   Coding: 26001012973C5D010020180300005D0C431C660882010261000000020000
   Shop #: WSC 31414 790 00001
   VCID: 73B3D0FFDBBB4FA2029-8026

   Subsystem 1 - Part No SW: 7P0 955 119     HW: 7P0 955 119   Labels: 1KX-955-119.CLB
   Component: WWS    120503  31  0020
   Serial number: 90243400120521170321
   Coding: 004DBD

   Subsystem 2 - Part No SW: 7P0 955 559 D    HW: 7P0 955 559 D  Labels: 8K0-955-559.CLB
   Component: RLFS  H09 0011
   Serial number: 10388717           
   Coding: 025223

   Subsystem 3 - Part No SW: 7P6 941 431 E    HW: 7P6 941 431 E
   Component: E1 - LDS  H04 0031
   Serial number: 00000000002205121003

   Subsystem 4 - Part No SW: 4H0 907 410 A    HW: 4H0 907 410 A
   Component: USHL4.2  H30 0020
   Serial number: 0000001805569R12DN07

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels:| 7P0-959-655.clb
   Part No SW: 7P0 959 655 C    HW: 7P0 959 655 C
   Component: VW10Airbag025 H05 0025 
   Revision: --------    Serial number: 003L0003E8FL Dataset Number: 7P6003v____ 0983
   Coding: 000000000000000000000000000000003235
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirbaVW10BPAVW526 001001
   ROD: EV_AirbaVW10BPAVW526_001.rod
   VCID: 41DF4A37D107AD32405-8014

   Seat occupied recognition:
   Subsystem 1 - Part No SW: 7P6 959 339     HW: 7P6 959 339
   Component: BF-Gewichtss.  003 0005
   Serial number: 5850000R12301089MT

   Crash sensor for side airbag: driver side:
   Serial number: 3575LRB405D1D5MSBPPG

   Front Passenger's Side Airbag Crash Sensor:
   Serial number: 3585LRB405F1D5MS506C

   Rear Side Airbag Crash Sensor (on driver's side):
   Serial number: 3515RRB405718B7489FT

   Passenger side rear thorax airbag crash sensor:
   Serial number: 3525RRB404P18B74F9OK

   Crash sensor for front airbag: driver side:
   Serial number: 3555NRB400M4UE2051G5

   Crash sensor for front airbag: front passenger side:
   Serial number: 3565NRB400M4UE20D0RO

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527)       Labels:. 4H0-953-568.clb
   Part No SW: 4H0 953 568 F    HW: 7P6 953 507 L
   Component: Lenks.Modul   H03 0005 
   Revision: --------    Serial number: 90815LEP0004J
   Coding: 000015
   Shop #: WSC 31414 790 00001
   VCID: 363529EB88491A8AE57-8062

   Subsystem 1 - Part No SW: 7P6 959 542     HW: 7P6 959 542
   Component: E221__MFL-TAS  H03 0027
   Serial number: 0183151             

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 7P6-920-xxx-17.clb-SRI1
   Part No SW: 7P6 920 981 F    HW: 7P6 920 981 F
   Component: Kombi         H14 0318 
   Revision: 14240078    Serial number: 658250512592025
   Coding: 8B7733022B00CF05020004
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_KombiUDSRBVW526 001017
   ROD: EV_KombiUDSRBVW526.rod
   VCID: 40D94F33DA0DA43A4FB-8014

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:* None
   Part No SW: 7P6 907 530 F    HW: 7P6 907 530 F
   Component: GW-CAN-L-MOST H10 6028 
   Revision: --------    Serial number: 00000000549394 Dataset Number: 7P6067v____ 0022
   Coding: 0001037500
   Shop #: WSC 31414 790 00001
   GVL: FB0F40451D7F000000
   ASAM Dataset: EV_GatewVW526UDS 001007
   ROD: EV_GatewUDS_VW52.rod
   VCID: 3B2338DFB3EBC7E21A9-806E

   Battery Monitoring Control Module:
   Subsystem 1 - Part No SW: 7P0 915 181 A    HW: 7P0 915 181
   Component: Batt_Sensor  H07 0140
   Serial number: 00000000005650422198

No fault code found.

-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136)       Labels: None
   Part No SW: 4H0 959 760 D    HW: 4H0 959 760 D
   Component: MEM-FS        H08 0153 
   Revision: AA000000    Serial number: 00000030085187
   Coding: 0058130000004001000001010101202020202121202020
   Shop #: WSC 31414 790 00001
   VCID: 343113E39E35089ADB3-8060

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:. 4H0-959-793.clb
   Part No SW: 4H0 959 793 N    HW: 4H0 959 793 F
   Component: TSG FA        H07 0166 
   Revision: --------    Serial number: 0000127939530
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 44D14323CE95B81A6B3-8010

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv. (J393)       Labels:. 4H0-907-064-46.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H32 0333 
   Revision: 00002001    Serial number: 0177139760   
   Coding: 0186123A28B9509480A00620210000000000000000000000000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B3D0FFDBBB4FA2029-8026

   Subsystem 1 - Part No SW: 7P6 959 719     HW: 7P6 959 719
   Component: GTO BT  H19 0059
   Serial number: 1151212846         

   Subsystem 2 - Part No: 1K0 951 605 C
   Component: LIN BACKUP HO  H05 1501

   Subsystem 3 - Part No SW: 7P0 959 591 B    HW: 7P0 959 591 B
   Component: J245 PS30.055  H01 0008
   Serial number:     WOO1611144Z     
   Coding: 191100

   Subsystem 4 - Part No SW: 7P0 959 591 C    HW: 7P0 959 591 C
   Component: J394 PS30.055  H01 0008
   Serial number:     WOO1645013.     
   Coding: 191100

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:. 4H0-959-792.clb
   Part No SW: 4H0 959 792 F    HW: 4H0 959 792 F
   Component: TSG BF        H07 0166 
   Revision: --------    Serial number: 0000127799673
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 3B2338DFB36BC7E21A9-806E

No fault code found.

-------------------------------------------------------------------------------
Address 53: Parking Brake (J540-)       Labels:| 7P0-907-801.clb
   Part No SW: 7P0 907 801 F    HW: 7P0 907 801 F
   Component: EPB           H51 1201 
   Revision: 00000000    Serial number: C1252200183    Dataset Number:             A001
   Coding: 01040200
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_ParkbA7 000006
   ROD: EV_ParkbA7.rod
   VCID: 363529EB88C91A8AE57-8062

   Slave 3:

No fault code found.

-------------------------------------------------------------------------------
Address 55: Headlight Range (J745)       Labels:. 7P6-907-357.clb
   Part No SW: 7P6 907 357     HW: 7L6 907 357 C
   Component: AFS-ECU       H04 0110 
   Revision: --------    Serial number: -------------- Dataset Number: 7P0036v____ 0009
   Coding: 010A00010F000400
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeadlRegulVWAFS 005006
   ROD: EV_HeadlRegulVWAFS_VW52.rod
   VCID: 7CA1FBC3F66500DA533-8028

   Left_headlamp_power_output_stage:
   Subsystem 1 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo links  H01 0003
   Coding: 130000

   Right_headlamp_power_output_stage:
   Subsystem 2 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo rechts  H01 0003
   Coding: 130000

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (R)       Labels:. 4F0-035-0xx-56.clb
   Part No SW: 4G0 035 082 D    HW: 4G0 035 082
   Component: Radio U SIRIU H60 0112 
   Revision: AB001007    Serial number: 156E30C7598444
   Coding: 020007020000000001
   Shop #: WSC 31414 790 00001
   VCID: 211FEAB731C78D32205-8074

No fault code found.

-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794)       Labels:. 4E0-035-6xx-5F.clb
   Part No SW: 7P6 035 664 C    HW: 7P6 035 664
   Component: H-BN-NA       H45 0544 
   Revision: --------    Serial number: 445E20C7535398
   Coding: 010200050040E1EE41022B0C00000003F0000100
   Shop #: WSC 31414 790 00001
   VCID: 382927D3825DECFAF7B-806C

   Subsystem 1 - Part No: 8R0 060 884 AM
   Component: NAR 2012  0605

   Subsystem 2 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9M7900ALW     

   Subsystem 3 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9M7900ALW     

   Subsystem 4 - Part No: 8R0 060 961
   Component: CD-Database  1886

No fault code found.

-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HL        H09 0167 
   Revision: --------    Serial number: 0000127808286
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2D3DDBBC51FEEA01F-806E

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502)       Labels: 3Y0-907-273.clb
   Part No SW: 7P6 907 273 F    HW: 7P6 907 273 F
   Component: RDKBERU25     H09 0008 
   Serial number: 10000000078587 Dataset Number: 7P6096v____ 0018
   ASAM Dataset: EV_RDKBERU25 003006
   ROD: EV_RDKBERU25_VW52.rod
   VCID: 3FDB4CCFA7F3DBC2361-806A

4 Faults Found:
8397058 - Front Left TPMS Sensor
          C1050 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18  C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV

8397314 - Front Right TPMS Sensor
          C1051 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18  C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV

8397570 - Rear Left TPMS Sensor
          C1052 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18  C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV

8397826 - Rear Right TPMS Sensor
          C1053 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18  C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV


-------------------------------------------------------------------------------
Address 69: Trailer (J345)       Labels: Redir Fail!
   Part No SW: 7P0 907 383 F    HW: 7P0 907 383 B
   Component: Anhaenger     H09 0110 
   Revision: 5A001001    Serial number: 00000176601350
   Coding: 020D000000000000
   Shop #: WSC 31414 790 00001
   VCID: 3B2338DFB36BC7E21A9-806E

No fault code found.

-------------------------------------------------------------------------------
Address 6C: Back-up Cam.        Labels: 4L0-910-441.clb
   Part No SW: 7P6 907 441 A    HW: 4H0 907 441
   Component: SG Rueckfahrkamera  0020 
   Revision: 00H06000    Serial number: 525 PA8J242660
   Coding: 0110001
   Shop #: WSC 31414 790 00001
   VCID: 372B24EF8343E382FE1-8062

No fault code found.

-------------------------------------------------------------------------------
Address 6D: Trunk Elect. (----)       Labels:| 7N0-959-107.clb
   Part No SW: 7P6 959 107 A    HW: 7P6 959 107
   Component: HDSG-Modul    H10 0620 
   Revision: 22010001    Serial number: 129200525 Dataset Number: 7P6959107A  D043
   Coding: 0533314003
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeckkTouar 202137
   ROD: EV_HeckkTouar.rod
   VCID: 3D2736C7ADFFC9D224D-8068

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HR        H09 0167 
   Revision: --------    Serial number: 0000127811258
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2D3DDBBC51FEEA01F-806E

No fault code found.

End----(Elapsed Time: 02:03, VBatt start/end: 11.8V/12.0V. VIgn 12.0V)-----
 
Discussion starter · #16 ·
thanks for all the help. From what I can tell the ECU wont clear the old codes without being prompted to. I finally got all codes cleared and vehicle appears to be operational (30 minute test drive). Here is how i had to clear the DPF codes:

Start Car
Open VCDS
Select control module
Open "01-Engine"
Click "Fault Codes - 02"
click "Clear Codes -05"
Open "Security Access - 16"
Enter security access key "27971" click 'Do it!'
Click "Basic Settings -04"
Select "IDE00467-Resetting of learned values of particle filter", Select "Go!"
Select "IDE00471-Service regeneration of particle filter", Select "Go!"
After pressing the break and gas pedal for about 5 minutes the DPF alarm cleared.

I'll start a new thread sharing my experience replacing the turbo and pulling the motor using a cherry picker.
 
#17 ·
I had a DPF fault and I replaced it back in March this year, a thread on it here somewhere which includes how I reset the computer so it knew the DPF had been replaced. I didn't see any mention that you had done that up until the last post. Plus of course all the above comments on your existing faults. I'd recommend that you get your existing readout under control and fully understand everything it says before any major surgery.
 
Save
Reply Quote Like Like
#19 ·
Sure, that doesn't matter as the computer generates an ash load reading and clean or replace, if that isn't reset then it continues to think that the ash load is still present. Half the issues are understanding how a quite old computer and basic software really "thinks". Life is simple once you are on top of that.
 
Save
Reply Quote Like Like
Discussion starter · #20 ·
Back here again. I've been driving the car around with no issues up until my drive home from work today when the check engine light came on (no limp mode this time). This time throwing multiple codes for NOx related issues. Any ideas if it's the sensor (would be the 3rd failed sensor in the past two months) or do i have a bigger issue somewhere?

Code: 
ATuesday,31,October,2023,16:18:48:58995
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 11 x64
VCDS Version: 23.3.1.0 (x64)  HEX-V2 CB: 0.4631.4
Data version: 20230421 DS346.2
www.Ross-Tech.com


VIN: WVGEP9BP3DD000603   License Plate: DKDKD
Mileage: 277817km-172627mi   Repair Order:



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: BP-VW52 (7P6)
Scan: 01 02 03 05 08 09 15 16 17 19 36 42 46 52 53 55 56 5F 62 65
          69 6C 6D 72

VIN: WVGEP9BP3DD000603   Mileage: 277817km-172627miles

01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
53-Parking Brake -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: Malfunction 0010
69-Trailer -- Status: OK 0000
6C-Back-up Cam. -- Status: OK 0000
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CNRB)       Labels:. 059-907-401-V2.clb
   Part No SW: 7P0 907 401 K    HW: 7P0 907 401 K
   Component: 3.0TDI FSA    H17 0011 
   Revision: 56H17---    CVN: E7FCBDE45C3E0D045C3E0D040E1FC39E
   Coding: 292A4012233600050000
   Shop #: WSC 23324 444 00000
   ASAM Dataset: EV_ECM30TDI0117P0907401K 001012
   ROD: EV_ECM30TDI0117P0907401K.rod
   VCID: 372B24EF8FC3E382FE1-8062
   VINID: 9E65D58094A00D45000001800C60B5CFBD

4 Faults Found:
9954 - NOx Reductant Consumption too Low
          P20F4 00 [168] - -
          MIL ON - Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 277786 km
                    Date: 2023.10.13
                    Time: 05:37:06

                    Engine RPM: 1855.00 /min
                    Normed load value: 64.7 %
                    Vehicle speed: 113 km/h
                    Coolant temperature: 96  C
                    Intake air temperature: 10  C
                    Ambient air pressure: 1000 mbar
                    Voltage terminal 30: 14.580 V
                    Unlearning counter according OBD: 40
                    Long-term adaptation of reduction agent dosage: 1.81
                    Measured NOx conversion range 1: 0.000
                    Efficiency threshold of NOx conversion range 1: 0.000
                    Mean temperature of SCR catalyst: 329.6  C
                    NOx sensor 1: NOx concentration: 184 ppm
                    NOx sensor 2: NOx concentration: 478 ppm
                    Particle filter: unburned fuel calculated: 0.001

9567 - NOx Sensor 2 Bank 1
          P229F 00 [237] - Implausible Signal
          MIL ON - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 277774 km
                    Date: 2023.10.12
                    Time: 19:27:06

                    Engine RPM: 1140.00 /min
                    Normed load value: 0.0 %
                    Vehicle speed: 59 km/h
                    Coolant temperature: 91  C
                    Intake air temperature: 3  C
                    Ambient air pressure: 1000 mbar
                    Voltage terminal 30: 14.800 V
                    Unlearning counter according OBD: 40
                    Exh r N Ox Pres Comp No Cat2 Ds: 352 ppm
                    NOx-Sensor 2: O2-Concentration: 0.20393
                    Oxygen sensor 1 bank 1: voltage raw value O2 signal: 1272.8 mV
                    Measured NOx conversion: 0.000
                    EGR Solen.val.: actual value: 99.95 %
                    Mean injection quantity: 0.00 mg/stroke
                    Exhaust gas temperature sensor 4: 347.0  C

9953 - Reductant Quality Performance
          P207F 00 [237] - -
          MIL ON - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 277786 km
                    Date: 2023.10.13
                    Time: 05:37:06

                    Engine RPM: 1853.00 /min
                    Normed load value: 63.9 %
                    Vehicle speed: 113 km/h
                    Coolant temperature: 96  C
                    Intake air temperature: 10  C
                    Ambient air pressure: 1000 mbar
                    Voltage terminal 30: 14.600 V
                    Unlearning counter according OBD: 40
                    Long-term adaptation of reduction agent dosage: 1.81
                    Measured NOx conversion range 1: 0.000
                    Efficiency threshold of NOx conversion range 1: 0.000
                    Mean temperature of SCR catalyst: 329.9  C
                    NOx sensor 1: NOx concentration: 184 ppm
                    NOx sensor 2: NOx concentration: 478 ppm
                    Particle filter: unburned fuel calculated: 0.001

17277 - SCR NOx Catalyst Bank 1
          P20EE 00 [101] - Efficiency too Low
          Not Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 277753 km
                    Date: 2023.10.12
                    Time: 19:15:14

                    Engine RPM: 1710.50 /min
                    Normed load value: 76.5 %
                    Vehicle speed: 104 km/h
                    Coolant temperature: 93  C
                    Intake air temperature: 2  C
                    Ambient air pressure: 1010 mbar
                    Voltage terminal 30: 14.800 V
                    Unlearning counter according OBD: 40
                    SCR efficiency test overall: 43.20 %
                    SCR error threshold of efficiency test: 45.00 %
                    SCR efficiency test 2: 0.443
                    SCR efficiency test 1: 0.425
                    Particle filter: unburned fuel calculated: 0.001
                    Mean temperature of SCR catalyst: 322.6  C
                    Long-term adaptation of reduction agent dosage: 1.54

Readiness: 1 3 0 1 1

-------------------------------------------------------------------------------
Address 02: Auto Trans (J217)       Labels:| 0C8-927-7XX-V1.clb
   Part No SW: 0C8 927 750 AK    HW: 0C8 927 750 A
   Component: AL1000 AISIN  001 3398 
   Serial number:                CVN: A4540B9E
   Coding: 001368
   Shop #: WSC 63090 001 1048576
   ASAM Dataset: EV_TCMAL991031 002115
   ROD: EV_TCMAL991031_002_VW52.rod
   VCID: 75B7EEE7D54F51922CD-8020

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:* 7P0-907-379.clb
   Part No SW: 7P0 907 379 M    HW: 7P0 907 379 A
   Component: MK25A         H36 0436 
   Revision: --------    Serial number: 414020010EC815 Dataset Number: 7P0012v____ 7P16
   Coding: 5B7613C349242553DAFAC89392D5A4407300
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_MK25AXT 008001
   ROD: EV_ESPMK25A00800.rod
   VCID: 47CB542FFF2393028E1-8012

No fault code found.

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393)       Labels:. 8K0-907-064-05.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H32 0333 
   Revision: 00002001   
   Coding: 09860010000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B3D0FFDBBB4FA2029-8026

   Subsystem 1 - Part No SW: 7P6 959 754 M    HW: 7P6 959 754 M
   Component: FBSTOUAREGIDG  H04 0051
   Serial number: 0512000023605013   

   Subsystem 2 - Part No SW: 4H0 905 852 B    HW: 4H0 905 852 B
   Component: J764 ELV MLB  H40 0046
   Serial number: 2312000103820012   

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels:| 7P6-907-040.clb
   Part No SW: 7P6 907 040 BK    HW: 7P6 907 040 BK
   Component: Klima 2 Zonen H20 1305 
   Coding: B606200A80
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirCondiFront 004001
   ROD: EV_AirCondiFront_VW52.rod
   VCID: 7EA5F1CBE07912CA7D7-802A

2 Faults Found:
0296 - Control Module for Auxiliary Heater
          B10C0 31 [008] - No Signal
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 3
                    Fault Frequency: 1
                    Reset counter: 12
                    Mileage: 277736 km
                    Date: 2023.10.12
                    Time: 19:01:26

0243 - Function Restriction due to Faults in Other Modules
          U1113 00 [008] - -
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 8
                    Reset counter: 13
                    Mileage: 277661 km
                    Date: 2023.10.09
                    Time: 23:16:59


-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 4H0-907-063-V1.clb
   Part No SW: 4H0 907 063 BL    HW: 4H0 907 063 D
   Component: BCM1 2.0      H12 0111 
   Revision: 15012002    Serial number: 00000001337544
   Coding: 26001012973C5D010020180300005D0C431C660882010261000000020000
   Shop #: WSC 31414 790 00001
   VCID: 73B3D0FFDBBB4FA2029-8026

   Subsystem 1 - Part No SW: 7P0 955 119     HW: 7P0 955 119   Labels: 1KX-955-119.CLB
   Component: WWS    120503  31  0020
   Serial number: 90243400120521170321
   Coding: 004DBD

   Subsystem 2 - Part No SW: 7P0 955 559 D    HW: 7P0 955 559 D  Labels: 8K0-955-559.CLB
   Component: RLFS  H09 0011
   Serial number: 10388717           
   Coding: 025223

   Subsystem 3 - Part No SW: 7P6 941 431 E    HW: 7P6 941 431 E
   Component: E1 - LDS  H04 0031
   Serial number: 00000000002205121003

   Subsystem 4 - Part No SW: 4H0 907 410 A    HW: 4H0 907 410 A
   Component: USHL4.2  H30 0020
   Serial number: 0000001805569R12DN07

2 Faults Found:
01855 - Temperature Sensor for Heated Seat; Left Front (G344)
            012 - Electrical Fault in Circuit - Intermittent
             Freeze Frame:
                    Fault Status: 00101100
                    Fault Priority: 2
                    Fault Frequency: 7
                    Reset counter: 13
                    Mileage: 277661 km
                    Time Indication: 0
                    Date: 2023.10.09
                    Time: 23:16:00

01856 - Temperature Sensor for Heated Seat; Front Right (G345)
            012 - Electrical Fault in Circuit - Intermittent
             Freeze Frame:
                    Fault Status: 00101100
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 8
                    Mileage: 277661 km
                    Time Indication: 0
                    Date: 2023.10.09
                    Time: 23:17:00


-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels:| 7P0-959-655.clb
   Part No SW: 7P0 959 655 C    HW: 7P0 959 655 C
   Component: VW10Airbag025 H05 0025 
   Revision: --------    Serial number: 003L0003E8FL Dataset Number: 7P6003v____ 0983
   Coding: 000000000000000000000000000000003235
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_AirbaVW10BPAVW526 001001
   ROD: EV_AirbaVW10BPAVW526_001.rod
   VCID: 41DF4A37D107AD32405-8014

   Seat occupied recognition:
   Subsystem 1 - Part No SW: 7P6 959 339     HW: 7P6 959 339
   Component: BF-Gewichtss.  003 0005
   Serial number: 5850000R12301089MT

   Crash sensor for side airbag: driver side:
   Serial number: 3575LRB405D1D5MSBPPG

   Front Passenger's Side Airbag Crash Sensor:
   Serial number: 3585LRB405F1D5MS506C

   Rear Side Airbag Crash Sensor (on driver's side):
   Serial number: 3515RRB405718B7489FT

   Passenger side rear thorax airbag crash sensor:
   Serial number: 3525RRB404P18B74F9OK

   Crash sensor for front airbag: driver side:
   Serial number: 3555NRB400M4UE2051G5

   Crash sensor for front airbag: front passenger side:
   Serial number: 3565NRB400M4UE20D0RO

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527)       Labels:. 4H0-953-568.clb
   Part No SW: 4H0 953 568 F    HW: 7P6 953 507 L
   Component: Lenks.Modul   H03 0005 
   Revision: --------    Serial number: 90815LEP0004J
   Coding: 000015
   Shop #: WSC 31414 790 00001
   VCID: 363529EB88491A8AE57-8062

   Subsystem 1 - Part No SW: 7P6 959 542     HW: 7P6 959 542
   Component: E221__MFL-TAS  H03 0027
   Serial number: 0183151             

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 7P6-920-xxx-17.clb-SRI1
   Part No SW: 7P6 920 981 F    HW: 7P6 920 981 F
   Component: Kombi         H14 0318 
   Revision: 14240078    Serial number: 658250512592025
   Coding: 8B7733022B00CF05020004
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_KombiUDSRBVW526 001017
   ROD: EV_KombiUDSRBVW526.rod
   VCID: 40D94F33DA0DA43A4FB-8014

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:* None
   Part No SW: 7P6 907 530 F    HW: 7P6 907 530 F
   Component: GW-CAN-L-MOST H10 6028 
   Revision: --------    Serial number: 00000000549394 Dataset Number: 7P6067v____ 0022
   Coding: 0001037500
   Shop #: WSC 31414 790 00001
   GVL: FB0F40451D7F000000
   ASAM Dataset: EV_GatewVW526UDS 001007
   ROD: EV_GatewUDS_VW52.rod
   VCID: 3B2338DFB3EBC7E21A9-806E

   Battery Monitoring Control Module:
   Subsystem 1 - Part No SW: 7P0 915 181 A    HW: 7P0 915 181
   Component: Batt_Sensor  H07 0140
   Serial number: 00000000005650422198

No fault code found.

-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136)       Labels: None
   Part No SW: 4H0 959 760 D    HW: 4H0 959 760 D
   Component: MEM-FS        H08 0153 
   Revision: AA000000    Serial number: 00000030085187
   Coding: 0058130000004001000001010101202020202121202020
   Shop #: WSC 31414 790 00001
   VCID: 343113E39E35089ADB3-8060

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:. 4H0-959-793.clb
   Part No SW: 4H0 959 793 N    HW: 4H0 959 793 F
   Component: TSG FA        H07 0166 
   Revision: --------    Serial number: 0000127939530
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 44D14323CE95B81A6B3-8010

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv. (J393)       Labels:. 4H0-907-064-46.clb
   Part No SW: 4H0 907 064 BK    HW: 4H0 907 064 BK
   Component: BCM2 2.0      H32 0333 
   Revision: 00002001    Serial number: 0177139760   
   Coding: 0186123A28B9509480A00620210000000000000000000000000000000000
   Shop #: WSC 31414 790 00001
   VCID: 73B3D0FFDBBB4FA2029-8026

   Subsystem 1 - Part No SW: 7P6 959 719     HW: 7P6 959 719
   Component: GTO BT  H19 0059
   Serial number: 1151212846         

   Subsystem 2 - Part No: 1K0 951 605 C
   Component: LIN BACKUP HO  H05 1501

   Subsystem 3 - Part No SW: 7P0 959 591 B    HW: 7P0 959 591 B
   Component: J245 PS30.055  H01 0008
   Serial number:     WOO1611144Z     
   Coding: 191100

   Subsystem 4 - Part No SW: 7P0 959 591 C    HW: 7P0 959 591 C
   Component: J394 PS30.055  H01 0008
   Serial number:     WOO1645013.     
   Coding: 191100

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:. 4H0-959-792.clb
   Part No SW: 4H0 959 792 F    HW: 4H0 959 792 F
   Component: TSG BF        H07 0166 
   Revision: --------    Serial number: 0000127799673
   Coding: 011D07205E00453005080000
   Shop #: WSC 31414 790 00001
   VCID: 3B2338DFB36BC7E21A9-806E

1 Fault Found:
02123 - Door Warning Light / Entry Light
            012 - Electrical Fault in Circuit
             Freeze Frame:
                    Fault Status: 01101100
                    Fault Priority: 3
                    Fault Frequency: 1
                    Reset counter: 223
                    Mileage: 277660 km
                    Time Indication: 0
                    Date: 2023.10.09
                    Time: 23:13:35


-------------------------------------------------------------------------------
Address 53: Parking Brake (J540-)       Labels:| 7P0-907-801.clb
   Part No SW: 7P0 907 801 F    HW: 7P0 907 801 F
   Component: EPB           H51 1201 
   Revision: 00000000    Serial number: C1252200183    Dataset Number:             A001
   Coding: 01040200
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_ParkbA7 000006
   ROD: EV_ParkbA7.rod
   VCID: 363529EB88C91A8AE57-8062

   Slave 3:

No fault code found.

-------------------------------------------------------------------------------
Address 55: Headlight Range (J745)       Labels:. 7P6-907-357.clb
   Part No SW: 7P6 907 357     HW: 7L6 907 357 C
   Component: AFS-ECU       H04 0110 
   Revision: --------    Serial number: -------------- Dataset Number: 7P0036v____ 0009
   Coding: 010A00010F000400
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeadlRegulVWAFS 005006
   ROD: EV_HeadlRegulVWAFS_VW52.rod
   VCID: 7CA1FBC3F66500DA533-8028

   Left_headlamp_power_output_stage:
   Subsystem 1 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo links  H01 0003
   Coding: 130000

   Right_headlamp_power_output_stage:
   Subsystem 2 - Part No SW: 8U0 941 329     HW: 8U0 941 329   Labels: 3D0-941-329.CLB
   Component: LeiMo rechts  H01 0003
   Coding: 130000

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (R)       Labels:. 4F0-035-0xx-56.clb
   Part No SW: 4G0 035 082 D    HW: 4G0 035 082
   Component: Radio U SIRIU H60 0112 
   Revision: AB001007    Serial number: 156E30C7598444
   Coding: 020007020000000001
   Shop #: WSC 31414 790 00001
   VCID: 211FEAB731C78D32205-8074

No fault code found.

-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794)       Labels:. 4E0-035-6xx-5F.clb
   Part No SW: 7P6 035 664 C    HW: 7P6 035 664
   Component: H-BN-NA       H45 0544 
   Revision: --------    Serial number: 445E20C7535398
   Coding: 010200050040E1EE41022B0C00000003F0000100
   Shop #: WSC 31414 790 00001
   VCID: 382927D3825DECFAF7B-806C

   Subsystem 1 - Part No: 8R0 060 884 AM
   Component: NAR 2012  0605

   Subsystem 2 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9M7900ALW     

   Subsystem 3 - Part No SW: 7P6 919 603 C    HW: 7P6 919 603 C
   Component: DU8 SV Touch  H26 0045
   Serial number: VWZ8Z9M7900ALW     

   Subsystem 4 - Part No: 8R0 060 961
   Component: CD-Database  1886

No fault code found.

-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HL        H09 0167 
   Revision: --------    Serial number: 0000127808286
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2D3DDBBC51FEEA01F-806E

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502)       Labels: 3Y0-907-273.clb
   Part No SW: 7P6 907 273 F    HW: 7P6 907 273 F
   Component: RDKBERU25     H09 0008 
   Serial number: 10000000078587 Dataset Number: 7P6096v____ 0018
   ASAM Dataset: EV_RDKBERU25 003006
   ROD: EV_RDKBERU25_VW52.rod
   VCID: 3FDB4CCFA7F3DBC2361-806A

4 Faults Found:
8397058 - Front Left TPMS Sensor
          C1050 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18  C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV

8397314 - Front Right TPMS Sensor
          C1051 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18  C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV

8397570 - Rear Left TPMS Sensor
          C1052 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18  C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV

8397826 - Rear Right TPMS Sensor
          C1053 31 [009] - No Signal
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 1
                    Fault Frequency: 1
                    Reset counter: 64
                    Mileage: 268337 km
                    Date: 2023.05.13
                    Time: 06:42:33

                    Vehicle speed: 100 km/h
                    Outside temperature: 18  C
                    Reception level antenna 1: 700 mV
                    Offset level antenna 1: 650 mV


-------------------------------------------------------------------------------
Address 69: Trailer (J345)       Labels: Redir Fail!
   Part No SW: 7P0 907 383 F    HW: 7P0 907 383 B
   Component: Anhaenger     H09 0110 
   Revision: 5A001001    Serial number: 00000176601350
   Coding: 020D000000000000
   Shop #: WSC 31414 790 00001
   VCID: 3B2338DFB36BC7E21A9-806E

No fault code found.

-------------------------------------------------------------------------------
Address 6C: Back-up Cam.        Labels: 4L0-910-441.clb
   Part No SW: 7P6 907 441 A    HW: 4H0 907 441
   Component: SG Rueckfahrkamera  0020 
   Revision: 00H06000    Serial number: 525 PA8J242660
   Coding: 0110001
   Shop #: WSC 31414 790 00001
   VCID: 372B24EF8343E382FE1-8062

No fault code found.

-------------------------------------------------------------------------------
Address 6D: Trunk Elect. (----)       Labels:| 7N0-959-107.clb
   Part No SW: 7P6 959 107 A    HW: 7P6 959 107
   Component: HDSG-Modul    H10 0620 
   Revision: 22010001    Serial number: 129200525 Dataset Number: 7P6959107A  D043
   Coding: 0533314003
   Shop #: WSC 31414 790 00001
   ASAM Dataset: EV_HeckkTouar 202137
   ROD: EV_HeckkTouar.rod
   VCID: 3D2736C7ADFFC9D224D-8068

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389)       Labels:. 4H0-959-795.clb
   Part No SW: 4H0 959 795 B    HW: 4H0 959 795 B
   Component: TSG HR        H09 0167 
   Revision: --------    Serial number: 0000127811258
   Coding: 011C07200000253005080000
   Shop #: WSC 31414 790 00001
   VCID: 3A2D3DDBBC51FEEA01F-806E

No fault code found.

End----------(Elapsed Time: 02:06, VBatt start/end: 12.5V/12.4V)-----------
 
1 - 20 of 21 Posts
About this Discussion
20 Replies
5 Participants
Last post:
SaVAGeSoot
Club Touareg Forum
posts
784K
members
105K
Since
2003
Club Touareg Forum is a forum community dedicated to Volkswagen Touareg owners and enthusiasts. Come join the discussion about VW Touareg Sport Utility Vehicles and more!
Full Forum Listing
Explore Our Forums
General Maintenance & Repair Australia & New Zealand Brakes, Steering, Suspension, Wheels and Tires Mobile Electronics and In Car Entertainment General Touareg Discussions