2004 R5 2.5tdi Limp Mode - Club Touareg Forums
 
Thread Tools Display Modes
post #1 of 6 Old 05-12-2017 Thread Starter
Junior Member
 
Touareg: 2004 R5 TDI
Join Date: Jul 2016
Location: Johannesburg South Africa
Posts: 37
Thanks: 0
Thanked 1 Time in 1 Post
2004 R5 2.5tdi Limp Mode

Hi Everyone

I decided to start a new thread. My vehicle is currently in Limp mode. Can someoneplease point me in the right direction?


VIN: WVGZZZ7LZ4D055059 License Plate:


Chassis Type: 7L (7L - VW Touareg (2003 > 11/2006))
Scan: 01 02 03 05 06 08 09 11 13 15 16 17 18 19 1C 22 29 32 34 36
37 39 3C 46 47 55 56 57 64 65 68 69 6C 6D 6E 75 76 77

VIN: WVGZZZ7LZ4D055059 Mileage: 415360km-258092miles
-------------------------------------------------------------------------------
Address 01: Engine Labels: Redir Fail!
Part No SW: 070 906 016 F HW: 028 101 125 8
Component: R5 2,5L EDC G000AG 5221
Revision: 12345678 Serial number: VWZ3Z0D1149959
Coding: 0001175
Shop #: WSC 31414 000 00000
VCID: 13724ED007621FEF80B-5160

1 Fault Found:
18049 - Please check DTC Memory of A/C Controller
P1641 - 000 - - Intermittent
Freeze Frame:
RPM: 0 /min
Torque: 168.0 Nm
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 12.01 V
Bin. Bits: 00001100
Temperature: 76.5°C
(no units): 144.0

Readiness: 0 0 X X X

-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 09D-927-750.lbl
Part No: 09D 927 750 BE
Component: AL 600 6Q 0465
Coding: 0004136
Shop #: WSC 03157 996 10325
VCID: 72BC2B5458B8B6E72BD-5160

2 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent - MIL ON
17225 - Transmission Fluid Pressure Sensor/Switch 1
P0841 - 010 - Implausible Signal - Intermittent - MIL ON

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 7L0-907-379-MK25.lbl
Part No: 7L0 907 379 D
Component: ESP ALLRAD MK25 0108
Coding: 0006145
Shop #: WSC 31414 000 00000
VCID: 3A2CC37440480EA723D-5160

2 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
01276 - ABS Hydraulic Pump (V64)
012 - Electrical Fault in Circuit

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. Labels: 3D0-909-13x-05.lbl
Part No SW: 3D0 909 135 J HW: 5WK 470 21
Component: Kessy 6400
Coding: 0000232
Shop #: WSC 31414 000 00000
VCID: 2C00F52CBA1CA017A11-5160

Subsystem 1 - Part No: XXXXXXXXXXX
Component: ELV XXXX

2 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
01299 - Diagnostic Interface for Data Bus (J533)
005 - No or Incorrect Basic Setting / Adaptation - Intermittent

-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 7L6-907-040.clb
Part No: 7L6 907 040 H
Component: CLIMAtronic R/L X 3716
Coding: 0000020
Shop #: WSC 31414 000 00000
VCID: 3536D0486956E1DFCEF-5160

3 Faults Found:
02508 - Temperature Sensor for Refrigerant (G454)
010 - Open or Short to Plus
00819 - High Pressure Sensor (G65)
009 - Open or Short to Ground - Intermittent
00445 - Loss of Refrigerant
015 - Cannot Be Tested at this Time
Freeze Frame:
Temperature: 52.0°C
RPM: 0 /min
Absolute Pres.: 10.0 bar
Load: 0.0 %
Temperature: 35.0°C
Temperature: 35.0°C
Load: 0.0 %
Temperature: 84.0°C


-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 7Lx-937-049-V1.clb
Part No: 7L6 937 049 K
Component: 2703
Coding: 0098428
Shop #: WSC 03203 996 83328
VCID: 44D0BD8C328C4857491-5160

5 Faults Found:
00968 - Right Turn Signals
014 - Defective - Intermittent
00979 - Lamp for Low Beam; Right (M31)
010 - Open or Short to Plus - Intermittent
00907 - Intervention load Management
000 - -
01520 - Rain and Light Recognition Sensor (G397)
008 - Implausible Signal - Intermittent
02195 - Dimmer Switch Instrument Panel & Switch Lighting (E20)
008 - Implausible Signal - Intermittent

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 3D0-909-601.lbl
Part No: 3D0 909 601 E
Component: 0B Airbag 8.4E+ H10 0951
Coding: 0012354
Shop #: WSC 31414 000 00000
VCID: 25160008D9F6915F7EF-5160

2 Faults Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
01578 - Airbag Deactivation Warning Lamp; Passenger Side (K145)
009 - Open or Short to Ground - Intermittent

-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 7L6-953-549.lbl
Part No: 7L6 953 549 D
Component: Lenksäulenmodul 3301
Coding: 0000031
Shop #: WSC 31414 000 00000
VCID: 40D8B19C269454776D9-5160

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments Labels: 7L6-920-xxx-7LA.lbl
Part No: 7L6 920 870 L
Component: KOMBIINSTRUMENT RB4 1821
Coding: 0007721
Shop #: WSC 31414 000 00000
VCID: 3FDAB2605B6A2B8F143-5160

1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 6N0-909-901-19.lbl
Part No: 6N0 909 901
Component: Gateway K<>CAN 0101
Coding: 0000006
Shop #: WSC 03203 996 83328
VCID: 70B8215C56B484F7DD9-5160

1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 22: AWD Labels: None
Part No: 0AD 927 755 BE
Component: TRANSFERCASE 0122
Shop #: WSC 00000 000 00000
VCID: 7F5AF2601BEAEB8F543-5160

1 Fault Found:
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 32: Differential Locks Labels: None
Part No: 0AC 927 771 B
Component: SG-Quersperre 5018
Shop #: WSC 00000 000 00000
VCID: 372ADA40735A13CFDC3-5160

2 Faults Found:
01314 - Engine Control Module
004 - No Signal/Communication
01317 - Control Module in Instrument Cluster (J285)
004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 7L0-959-933.lbl
Part No: 7L0 959 933 E
Component: 1S HSG 0201
Coding: 0000081
Shop #: WSC 03203 996 83328
VCID: 3E24CF645C6022871F5-4B00

Subsystem 1 - Part No: 7L0 959 701 C
Component: Tuersteuergeraet FS 0104

Subsystem 2 - Part No: 7L0 959 702 C
Component: Tuersteuergeraet BF 0104

Subsystem 3 - Part No: 7L0 959 703
Component: Tuersteuergeraet HL 0201

Subsystem 4 - Part No: 7L0 959 704
Component: Tuersteuergeraet HR 0201

Subsystem 5 - Part No: 7L0 907 719
Component: Neigungssensor 0020

Subsystem 6 - Part No: 7L6 951 171
Component: A Innenraumsensor 0019

6 Faults Found:
00849 - S-contact at Ignition/Starter Switch (D)
008 - Implausible Signal - Intermittent
00985 - Right Tail Light (M2)
009 - Open or Short to Ground - Intermittent
00987 - Lamp for Brake Light; Left (M9)
009 - Open or Short to Ground - Intermittent
00988 - Lamp for Brake Light; Right (M10)
009 - Open or Short to Ground - Intermittent
00912 - Window Regulator Switch; Front Left (E40)
007 - Short to Ground - Intermittent
00931 - Locking Module for Central Locking; Rear Right (F223)
008 - Implausible Signal - Intermittent

-------------------------------------------------------------------------------
Address 47: Sound System Labels:
VCID: 55F670C8CC06C1DF2EF-5160
Note: Excessive Comm Errors


-------------------------------------------------------------------------------
Address 56: Radio Labels: 3B7-035-1xx-56.lbl
Part No: 7L6 035 195 A
Component: Radio DE2 0012
Coding: 0001017
Shop #: WSC 31414 000 00000
VCID: 313EE4589D3ECDFF927-5160

1 Fault Found:
00857 - CD Changer Unit (R41)
004 - No Signal/Communication

-------------------------------------------------------------------------------
Address 68: Wiper Electr. Labels: None
Part No: 7L0 955 119 G
Component: Front Wiper 2416
Coding: 0000004
Shop #: WSC 03203 996 378240
VCID: 3828D97C7E441CB7D59-5160

2 Faults Found:
01520 - Rain and Light Recognition Sensor (G397)
011 - Open Circuit - Intermittent
01520 - Rain and Light Recognition Sensor (G397)
014 - Defective

End----------(Elapsed Time: 13:09, VBatt start/end: 11.6V/11.6V)-----------

Sent from my SM-A500F using Tapatalk
Treg1986 is offline  
Sponsored Links
Advertisement
 
post #2 of 6 Old 05-12-2017
Touareg Mechanic
 
Touareg: 2014 V6 TDI
Join Date: May 2016
Location: Mile High
Second Vehicle: too many to list
Posts: 682
Thanks: 0
Thanked 33 Times in 32 Posts
Looks like you need to start fixing stuff.

I would start with the ignition switch.

---
That is the difference between you and me, I never go back to the carpet store.
-Rick


To view links or images in signatures your post count must be 0 or greater. You currently have 0 posts.


My VW youtube Channel:
To view links or images in signatures your post count must be 0 or greater. You currently have 0 posts.
Xeno555 is offline  
post #3 of 6 Old 05-12-2017
Touareg Addict
 
Oregon TDI's Avatar
 
Touareg: Still looking
Join Date: Feb 2015
Location: Oregon
Second Vehicle: Other
Posts: 1,953
Thanks: 141
Thanked 203 Times in 160 Posts
Garage
How old is the battery (or batteries)? You have so many faults it suggests an electrical problem.
Oregon TDI is offline  
Sponsored Links
Advertisement
 
post #4 of 6 Old 05-13-2017 Thread Starter
Junior Member
 
Touareg: 2004 R5 TDI
Join Date: Jul 2016
Location: Johannesburg South Africa
Posts: 37
Thanks: 0
Thanked 1 Time in 1 Post
Quote:
Originally Posted by Oregon TDI View Post
How old is the battery (or batteries)? You have so many faults it suggests an electrical problem.
I'm going to check the voltage just now as it sat overnight. I did see it dropped to about 11v after the test

Sent from my SM-A500F using Tapatalk
Treg1986 is offline  
post #5 of 6 Old 05-13-2017 Thread Starter
Junior Member
 
Touareg: 2004 R5 TDI
Join Date: Jul 2016
Location: Johannesburg South Africa
Posts: 37
Thanks: 0
Thanked 1 Time in 1 Post
Okay so my mate brought a new battery because I got stuck.....put it in got it back to my yard and now I see the van swings but takes a while to start so I scanned it and picked this error up.

Sent from my SM-A500F using Tapatalk
Treg1986 is offline  
post #6 of 6 Old 05-13-2017 Thread Starter
Junior Member
 
Touareg: 2004 R5 TDI
Join Date: Jul 2016
Location: Johannesburg South Africa
Posts: 37
Thanks: 0
Thanked 1 Time in 1 Post
17949 fuel pump relay

Sent from my SM-A500F using Tapatalk
Treg1986 is offline  
Reply

Quick Reply
Message:
Options

Register Now



In order to be able to post messages on the Club Touareg Forums forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in










Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode



Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off

 
For the best viewing experience please update your browser to Google Chrome
 

VW Touareg News Delivered to your Email!

Stay up-to-date with Touareg news in your inbox.

unsusbcribe at anytime with one click

Close [X]